LD2668 .T4 1966 D44 / Master of Science

Call number: LD2668 .T4 1985 M377 / Master of Science

Master of Science / Department of Grain Science and Industry / Leland McKinney / Carryover of medicated feed additives between batches of feed can potentially result in harmful drug residues in the edible tissues of food-animals. Flushing the equipment with an ingredient, such as ground grain, is one method used to remove any residual medicated feed from the system. It is generally recommended that the quantity of flush used be between 5 and 10% of the mixer's capacity. However, there is little data that supports this recommendation. Therefore, two experiments were conducted to 1.)determine which manufacturing equipment is the major source of carryover, 2.)evaluate which flush size adequately prevents drug carryover, and 3.) quantify the interrelationship between flush size and drug concentration. In Experiment 1, feed medicated with nicarbazin (Nicarb 25%®; 0.0125%) was manufactured and conveyed from the mixer, through a drag conveyor and bucket elevator, and then into a finished product bin. The system was then flushed using ground corn in the amount of 2.5, 5, 10, 15, or 20% of the mixer's capacity (454.5 kg). Subsequently, a non-medicated diet was conveyed through the system and samples were collected and analyzed for nicarbazin. No significant (P > 0.05) differences were detected among the flush treatments, and all treatments were effective in preventing nicarbazin carryover to the non-medicated diet. In Experiment 2, feed medicated with three levels of monensin (Rumensin® 80; 100, 600, and 1,200 g/ton) was manufactured and handled in the same manner as in Experiment 1. The flushing treatments examined were: 1, 2.5, and 5% of the mixer's capacity. Samples of the non-medicated diet for each treatment were collected and analyzed for monensin. There was significant interaction (P < 0.05)between drug level and sampling location between treatments. As the drug level in the medicated diet increased, higher concentrations of monensin were detected in the non-medicated diet. Collectively, these studies demonstrate that a 2.5%, even a 1% flush size, is effective in preventing carryover of medicated feed additives. It was also demonstrated that the bucket elevator and finished product bin were the major sources of drug carryover in this particular feed manufacturing system.

No description available.

An experiment involving three feeding trials was conducted to study the effect of substituting chopped wheat straw for alfalfa in diets for lactating dairy cows. The results of these trials have shown that in complete mixed diets or diets containing long alfalfa hay, replacement of half of the alfalfa in rations containing 45% roughage for lactating dairy cows with chopped wheat straw does not adversely affect DM intake or milk yield and increase milk fat percentage. Replacing half of the long alfalfa with chopped alfalfa also apparently improved lactational performance although not as dramatically as that of chopped straw. Ammoniation of wheat straw did not improve the performance response by lactating cows. Inclusion of chopped straw in the diets seemed to enhance the efficiency of milk production. Higher ruminal acetate:propionate ratios and increased digestibility of ether extract resulted from feeding straw. Digestibility of other nutrients were generally either not affected or were depressed by straw feeding. Increasing the chopped wheat straw level to 75% of the roughage resulted in lower DM intake and milk yield and negative body weight gains but higher milk fat levels. It did not appear that maintenance of constant ADF level in a dairy ration regardless of roughage level was the solution to the maintenance of milk fat levels. Thus it has been indicated that under the conditions of this experiment a combination of chopped alfalfa and wheat straw can be used successfully in complete mixed rations for high producing dairy cows. For the most part all productive parameters measured were improved by the addition of straw and by the feeding of complete mixed diets. This was especially true for milk fat which, from a dairyman's viewpoint, is very important because of its impact on milk pricing. It would also have a direct bearing on management by reducing labor costs through elimination of labor intensive handling of long alfalfa. Mechanical handling of complete mixed rations is relatively easier and cheaper.

No description available.

No description available.

No description available.

Zygomycetes is a class of fungi living worldwide as saprobes, as part of mycorrhizae, and as parasites. Humans have used some zygomycetes for centuries in the production of traditional foods, e.g. Indonesian tempe. In the present thesis, the experimental focus was on two zygomycetes strains, Mucor indicus CCUG 22424 and Rhizopus sp. IT. One of the distinguishing features of M. indicus is its dimorphism. The different cell forms were influenced by the culturing conditions. After inoculation, when the initial spore concentration was high (6-8×106 spores/ml), yeast-like growth dominated under anaerobic conditions. With a smaller inoculum, yielding 1-2×105 spores/ml, and access to oxygen, filamentous forms dominated. Only negligible differences in ethanol yield (390-420 mg/g hexoses), productivity (3-5 g/l/h), and inhibitor tolerance were observed. Differential expressions of probably four genes were observed between the yeast-like and filamentous growth forms. Lignocelluloses are a suitable substrate for cultivating zygomycetes, as they occur in abundance, particularly since zygomycetes, unlike Saccharomyces cerevisiae, can utilise pentoses. Lignocelluloses require pretreatment to achieve efficient hydrolysis of the cellulose. N-methylmorpholine-N-oxide (NMMO) was tested for pretreatment of spruce and birch. Reducing wood chip size and/or prolonged pretreatment, promoted hydrolysis yield. Best yields were achieved from &lt;2 mm chips and 5 h pretreatment. The hydrolysate was used for fermentation with M. indicus, resulting in 195 and 175 mg ethanol/g wood, and 103 and 86 mg fungal biomass/g wood, from spruce and birch respectively. Orange peel is another potential substrate. However, the hydrolysate contained 0.6 % (v/v) D-limonene, ten times higher than the concentration inhibiting S. cerevisiae. M. indicus was more resistant and successfully fermented the hydrolysate, producing 400 mg ethanol/g hexoses and 75 mg fungal biomass/g sugars. Both M. indicus and Rhizopus sp. grew in 1.0 % and 2.0 % D-limonene, although the latter was unable to grow in the hydrolysate. A third substrate was also used, spent sulphite liquor (SSL), which is a by-product from sulphite paper pulp mills. The SSL was diluted to 50 % and used for airlift cultivations of Rhizopus sp. In 1.0 vvm aeration, up to 340 mg biomass/g sugars was produced. Prolonged cultivations generally decreased the protein (from 500 to 300 mg/g) and lipid (from 70 to 20 mg/g) contents. In contrast, the cell wall fraction, measured as alkali-insoluble material (AIM), increased (160-280 mg/g), as did the glucosamine (GlcN) content (220-320 mg GlcN/g AIM). The produced fungal biomass could serve as animal feed, e.g. for fish. / <p>Akademisk avhandling som för avläggande av teknologie doktorsexamen vid Chalmers tekniska högskola försvaras vid offentlig disputation den 9 februari 2012, klockan 10.00 i KS101, Kemigården 4, Göteborg.</p>

Master of Science / Department of Animal Sciences and Industry / Joel DeRouchey / Thirteen experiments using a total of 7,589 nursery and finishing pigs were conducted to evaluate the effects of deoxynivalenol (DON), feed additives and processing conditions on nursery pig growth performance. In addition, feed withdrawal and diet blending were evaluated in finishing pigs. Experiment 1 tested 3 feed additives in DON-contaminated diets with only Defusion Plus improving performance. Experiment 2 evaluated Biofix in both low- and high-DON diets and showed no effects on growth. Experiments 3 and 4 further evaluated levels of Defusion and the effects of pelleting and supplemental nutrients in DON-contaminated diets. Defusion improved growth in low-DON diets, but had variable effects in high DON diets. Pelleting DON-contaminated diets resulted in comparable growth to pigs fed positive control diets in meal form. In Exp. 5 and 6, pilot studies evaluated DON-detoxification using sodium metabisulfite (SMB) with hydrothermal treatment in both an autoclave and a pellet mill. These conditions reduced analyzed DON by as much as 89 and 75% for the autoclave and pellet mill, respectively. In Exp. 7 and 8, pelleting DON-contaminated diets with SMB improved growth. Experiments 9 and 10 evaluated feed-withdrawal time on carcass composition and economic returns. These experiments showed that pre-slaughter fasting for up to 36 h prior can be used to avoid weight discounts in heavyweight pigs without negatively impacting carcass composition and maintaining overall revenue. However, these advantages come with a potential reduction in carcass weight and increased incidence of leaking ingesta, which can result in condemned heads. Experiments 11, 12, and 13 compared phase-feeding to blending diets using an automated feed delivery system. These studies showed that corn-supplement blending is not economical and feeding diets blended to a Lys curve results in lower feed costs compared to phase-feeding, but due to reductions in growth and carcass weight, these savings do not translate into higher income over feed cost. Finally, Exp. 13 showed that over- and under-budgeting situations do not significantly influence overall returns, but pigs fed under-budgeted diets performed more closely to those fed correctly estimated feed budgets.