It takes 3~5 years to finish a power plaint project including location, reliability, environment evaluating, investigation, etc. In addition, it is difficulty to get a right place and hinder by the environment protection. So, it is an important class on boosting the existing power generation capacity.
It was used to enhance power generation capacity by increasing the combustion chamber temperature in traditional way. However, it not only increases the exhaust temperature of gas turbine, but also increase the compressor ration. However, it is more difficulty on the design of gas turbine. And then we consider the other way in this thesis by reducing inlet air temperature of compressor to increase the density and flow of air and the power generation capacity. The result is magic that the power generation capacity enhance 10% ~20%.
The analysis of Combustion Turbine Inlet Air Cooling System by Absorption refrigerant system(CTIAC-ABS) describe in chapter 2 including fundamental of a gas turbine, the absorption refrigerant chiller, the inlet cooling coil and cogeneration system. It lets us know how to select the style of cogeneration and specification of an absorption refrigerant chiller.
It is important to consider the mass condensate water in the air side of inlet cooling coil. The author suggest to use the analysis method of wet-coil developed by Threlkeld(1970).
The CTIAC system could be used to the Gas Turbine System, Gas Turbine with HRSG System and Combined System. Because of there is not high pressure steam, we can use the fired-gas absorption refrigerant system as the source of chiller on the CTIAC-ABS system. There is the high pressure steam of Gas Turbine with HRSG System and Combined System. So we can divided the high pressure steam into two part, one to process and the other could be used as the heat source of absorption refrigerant chiller There are two advantages of using CTIAC-ABS on cogeneration power plaint.
1.The new purpose of mass high pressure steam could be used in cogeneration power plaint in Taiwan.
2.Reduction operational cost of CTIAC-ABS
The author finished the sensibility of power generation capacity with the analysis of practical operative data, classification of gas turbine and the power plaint Simulation program (GateCycle). When the compressor inlet temperature decrease from 30OC to 10OC, the results are : air flow rate increase 6.3%, fuel flow rate increase 5.95%, exhaust air temperature decrease 1.7% and exhaust air flow rate increase 6.3%, net power output increase 12.2%, heat rat decrease 3.7% and thermal efficiency upward 1.32%.Then, the author got a simulative equation of power capacity.
The typical gas turbines operate at full-load condition, 52.25% of annual hours, in 1998 in Taiwan. Gas turbines were almost full load on daytime and half-load or closed at night.
If we apply the CTIAC-ABS system on TPC's combined power plant, it can operate at 8:00~18:00 on daytime and shutdown at night. If there is high pressure steam in the cogeneration with HRSG, the CTIAC-ABS system can operate at the time that the cogeneration power plant is operative.
How to decide the capacity of absorption refrigerant chiller? The author decided the maximum capacity of absorption refrigerant chiller operating at 31OC , 80%RH of weather condition that limit by 2.5% ***. The author forecasts the lowest compressor inlet air temperature will be 10OC.
The steam double-effect CTIAC-ABS system could make the compressor inlet air temperature decrease from 30OC to 10 OC and enhances the heat rate 3.8%, the thermal efficiency 1.2%. The fired-direct CTIAC-ABS system also enhances the heat rate 5% and the thermal efficiency 1.5%. The results are close to the simulation of GateCycle program. So, the author compared the result of simulation with real data that the optimumal operative point of the CTIAC-ABS system is 10OC.
| Identifer | oai:union.ndltd.org:NSYSU/oai:NSYSU:etd-0609100-130955 |
| Date | 09 June 2000 |
| Creators | Lin, Dung-Lung, |
| Contributors | S.H,Wang, Kung-Hsung, Yang, Hsien-Te, Lin |
| Publisher | NSYSU |
| Source Sets | NSYSU Electronic Thesis and Dissertation Archive |
| Language | Cholon |
| Detected Language | English |
| Type | text |
| Format | application/pdf |
| Source | http://etd.lib.nsysu.edu.tw/ETD-db/ETD-search/view_etd?URN=etd-0609100-130955 |
| Rights | unrestricted, Copyright information available at source archive |
Page generated in 0.0022 seconds