An investigation was done into the recovery of invert sugar from sugar cane
molasses. A pilot plant was designed and constructed to evaluate the clarification
and separation of molasses to produce invert sugar syrup. The aim of the pilot
plant was to prove the process and deliver data so as to facilitate the design and
prove the financial viability of a commercial plant. The pilot plant had to process
300 kg/day of molasses.
The clarification of molasses by centrifugal separation, a known desludging
process, did not produce a product of acceptable quality which could be used in a
chromatographic separator. The results were disappointing. The product
obtained was also not suitable for dead end pressure filtration. The turbidity
remaining after the centrifugal separation also did not respond to a second
flocculation process.
Conventional settling clarification was investigated. Seven factors that could
influence the consolidation and settling of suspended solids in molasses were
identified, namely: the age of the diluted molasses, the temperature of the
flocculated mixture, the variations across various batches of flocculant, the effect of
reaction time of the phosphoric acid, the optimum flocculant dosing concentration,
the optimum concentration of the molasses solution and the effect of increasing the
acid dosage.
The optimum conditions to clarify molasses through settling were found to be: fresh
molasses, at 28 Brix and 60°C, allowing 10 min intervals between acidification with
3,75 g (as 100%) phosphoric acid/ kg dry material (assumed equal to Brix) and
neutralisation with 5 g (as 100%) caustic/kg dry material (assumed equal to Brix),
flocculation with any batch of flocculant 6195, dosed as a 1000 ppm solution.
Commercial equipment was evaluated. The pilot plant E-cat clarifier was operated
at 300 l/h and a thick sludge formed. The overflow was clear and it could be
filtered. The molasses obtained was suitable for chromatographic separation.
The recovery of sugars from molasses sludge has economic merit. From the
evaluation of centrifugal separation and gravity separation it is clear that gravity separation again is the best method. The sweet-water obtained is consistent within
the clarity requirement of 10 NTU/Brix and can be used to dilute raw molasses in
the upstream processing step. The clarification process that was developed is
patented. [Bekker, Stolz et.al. (2001)]
A sugar recovery of 93.9 mass % at a purity of 99.7 mass % from molasses, was
achieved using a simulated moving bed, ion exclusion, pilot plant. The operating
conditions for this performance were: feed flow at 14 l/h and at a temperature
above 60 °C; water flow at 63 l/h and at a temperature above 65 °C; extract flow at
21 l/h; raffinate flow at 56 l/h; loop flow at 78 l/h and step time at 1326 seconds.
This relates to the following bed volumes of the various separation zones: Bed
Volume Zone 1 = 0.694; Bed Volume Zone 2 = 0.591; Bed Volume Zone 3 =
0.661; Bed Volume Zone 4 = 0.383. There is a trade-off between purity and
recovery and a reduction in water usage.
A preliminary environmental impact assessment and conceptual mass balance
were done. The proposed plant integrates well into the existing Komati Mill of TSB
and does not pose any significant environmental threat. The plant requires certain
services from the mill. The mass balance investigated the water and steam
consumption of the plant. Process integration was done so as to obtain the
optimum utility consumption. The utility consumption of the plant does not exceed
the capacity available at the mill. A small boiler is however required to produce
steam during the annual mill maintenance period.
Various techniques were used in a cost estimation for the invert sugar plant. The
internal rate of return (IRR) is 42% for a fixed capital investment of
R94,270,000.00. The net return rate (NRR) for the project is 4%/year, the net
present value (NPV) - discounted at a 30% cost-of-capital is R41,782,000.00. The
net payout time (NPT) is 5.207 years. The project fulfils the financial requirements
set by TSB.
It is now possible and viable to desugarize cane molasses.
Identifer | oai:union.ndltd.org:netd.ac.za/oai:union.ndltd.org:sun/oai:scholar.sun.ac.za:10019.1/1986 |
Date | 03 1900 |
Creators | Stolz, Hendrik Nicolaas Petrus |
Contributors | Knoetze, J. H., University of Stellenbosch. Faculty of Engineering. Dept. of Process Engineering. |
Publisher | Stellenbosch : University of Stellenbosch |
Source Sets | South African National ETD Portal |
Language | English |
Detected Language | English |
Type | Thesis |
Rights | University of Stellenbosch |
Page generated in 0.0016 seconds