Thesis (MScEng (Process Engineering))--University of Stellenbosch, 2006 / Fouling is a serious problem in membrane filtration, caused by pore plugging and
adsorption of rejected macromolecules or other solutes in the membrane system.
This requires periodic cleaning of membranes, which can add considerably to the
overall cost of plant operation owing to lost productivity related to down-time, the
cost of the chemicals used in cleaning, higher pressures and associated pumping
costs to maintain membrane productivity, as well as reduced lifetime of the
membranes.
Ultrasound has recently been suggested as a promising approach to combating
fouling in membranes. In principle it can be used on-line and may even eliminate
the use of chemical cleaning or alternative measures completely, which could lead
to major advances in the development and implementation of membrane
technology. The objective of this investigation was therefore to assess the
feasibility of using ultrasound to mitigate fouling in capillary ultrafiltration
systems applied to water containing natural organic matter.
Experimental work was conducted with a small laboratory-scale capillary
membrane module. Ultrasound was introduced into the system by means of an
ultrasonic probe operating at a fixed frequency of approximately 30 kHz,
generating a maximum acoustic power density of 130 W/cm2 with a nominal
power output of 50 W (IKA Labortechnik Staufen, United Kingdom, U50).
Five systems were investigated, viz. aqueous solution of Congo Red dye,
ultrapure water, coloured ground water from the George region, water from the
Steenbras dam, as well as an aqueous solution of dextran. In most cases,
ultrasonication resulted in an increase in the permeate flux. This increase could
partly be attributed to an increase in the temperature and thus a decrease in the
viscosity of the fluid and partly to enhanced mass and energy transfer due to
sonication. Based on experiments done with the Congo Red dye and ultrapure
water, no damage as a result of ultrasonication could be discerned in the
membrane filter, except when there was direct contact between the ultrasonic
probe and the membrane materials. Permeate quality analyses confirmed that
sonication does not damage the membrane material – no degradation of
permeate quality was found specifically during sonication intervals.
In conclusion, ultrasound indeed appeared to be an effective approach to remove
foulants associated with natural organic matter from membranes. However, an
issue not addressed by this study, but apparent from the literature, is that the
effect of ultrasound is strictly local and this has major implications for the scaleup
of such ultrasound systems.
| Identifer | oai:union.ndltd.org:netd.ac.za/oai:union.ndltd.org:sun/oai:scholar.sun.ac.za:10019.1/2069 |
| Date | 03 1900 |
| Creators | Nel, A. M. |
| Contributors | Aldrich, C., University of Stellenbosch. Faculty of Engineering. Dept. of Process Engineering. |
| Publisher | Stellenbosch : University of Stellenbosch |
| Source Sets | South African National ETD Portal |
| Language | English |
| Detected Language | English |
| Type | Thesis |
| Rights | University of Stellenbosch |
Page generated in 0.0018 seconds