ABSTRACT Stirred yogurt is a cultured dairy product produced by mixed cultures of lactic acid bacteria. It is a semi-viscous liquid whose rheological properties are major quality determinants. These are influenced by several manufacturing factors such as heat treatment of the yogurt milk. Improvement of the properties of stirred yogurt made under different manufacturing conditions was the key focus in this research. The research included an investigation of the key factors involved in the development of nodulation which is an unsightly defect, as consumers expect stirred yogurt to have a smooth consistency. This research consisted of three main experimental parts: 1. Effect of different heat treatments on the properties of stirred yogurt; 2. Factors involved in nodulation in stirred yogurt; and 3. The physical and chemical nature of nodules. The types and levels of heat treatment have a major influence on the properties of stirred yogurt. In this study, yogurt milk was treated at pasteurization and UHT conditions. The milk heated at pasteurization, 80-95oC, and UHT, 130-145oC, conditions had similar levels of whey protein denaturation, approximately 85-99%, while the milk treated at low temperature for a long time, 65oC for 4 hr, had a significantly lower level of denaturation (~55%). Yogurt made from milk pasteurized at 85oC for 30 min and 92oC for 7 min and UHT treated milk at 130-145oC for 5 s had similar hardness and viscosity while yogurt made from milk treated at 65oC for 4 hr had significantly lower hardness and viscosity than corresponding yogurts from high heat treatments. In addition, the water-holding capacity and syneresis of yogurts made from either pasteurized or UHT milk were not significantly different. Yogurt (made from either pasteurized or UHT-treated milk) enriched with non-dairy ingredients, gelatin, inulin and sugar, showed higher hardness, viscosity, water-holding capacity than yogurt made with only dairy ingredients. These yogurts also showed no syneresis. This can be largely attributed to the gelatin which improves the texture, binds additional water and prevents syneresis. The formation of nodules in yogurt has been reported to be influenced by several factors. In this study, the heat treatment of the yogurt milk, the types and levels of sugar added, and the type of starter cultures were found to significantly influence the level of nodulation in the stirred yogurts. Severe pasteurization heat treatments, at temperatures < 100ºC, caused more nodules than mild heat treatments at temperatures in this range. The type of heat treatment was also important, with yogurt made from UHT-treated milk showing much less nodulation than yogurt made from pasteurized. This was observed when the levels of whey protein denaturation in the pasteurized and UHT milk were similar, indicating that the extent of whey protein denaturation alone is not a major factor in the development of nodules. Sucrose added either before or after heat treatment of yogurt milk also affected the extent of nodulation. Increasing the amount of added sucrose from 0 to 6.5% caused correspondingly higher numbers of nodules. In addition, there was a positive synergistic effect between heat treatment and sugar addition on nodulation; the highest numbers of nodules appeared when the yogurt milk was severely heated and sugar was added at the highest level, 6.5%. Addition of lactose or fructose instead of sucrose did not promote nodule formation while glucose caused nodulation in a similar manner to sucrose. The use of different starter cultures affected the numbers of nodules; yogurts made with the culture ABT 10 had much less nodulation than those made with ABT5 and ABT6, even under heating conditions and sugar addition conducive to nodule development. The amount of exopolysaccharide (EPS) produced by the starter cultures, ABT5 and ABT10, did not correlate with the extent of nodulation in the yogurt. Disturbance during yogurt fermentation by changing the temperature (from 37 to 42 or 45 to 42oC) when the gel was forming increased the numbers of nodules while refrigerated storage of yogurt and altering the pH during heat treatment (from pH 6.46 to 6.90) did not affect the number of nodules. Ultrasonication of the yogurt milk caused a reduction in the numbers of nodules in the yogurt. This was attributed to disruption of clumps of starter culture bacteria, thus preventing excessive localised build-up of acid around the bacterial clumps which could form the nucleus of nodules. The major conclusions from this study are that heat treatment of the yogurt milk and the level and type of added sugar are important factors affecting the extent of nodulation of stirred yogurt. Other factors such as the type of starter culture bacteria and their degree of clumping are also significant. Optimisation of these factors would allow yogurt manufacturers to minimise nodulation in stirred yogurt.
| Identifer | oai:union.ndltd.org:ADTP/253975 |
| Creators | Kanokkan Weeragul |
| Source Sets | Australiasian Digital Theses Program |
| Detected Language | English |
Page generated in 0.0016 seconds