To recover oil remaining in petroleum reservoirs after waterflooding, the gravitationally stable mode of gas injection is recognized as a promising tertiary oil recovery process. Understanding the phenomena occurring over the course of the gravity-assisted inert gas injection (GAIGI) process is thus important. Extensive studies on both secondary and tertiary modes of gravity drainage have shown promising results in recovering oil from homogeneous water-wet glass bead packs, sand packs, and sandstone cores, respectively. However, it is not realistic to anticipate similar flow mechanisms and recovery results in all types of reservoirs because the natural hydrocarbon reservoirs are all heterogeneous in terms of their permeability, porosity, and wettability. Such heterogeneities cause irregular displacement patterns, and nonuniform fluid distribution. The impact of heterogeneity of the porous media on the GAIGI process has not been fully addressed in the experimental studies carried out to date; therefore, this thesis aims to fill in the gap of knowledge on this area.
The impact of reservoir wettability and pore structure heterogeneities at the macroscopic scale on the recovery efficiency of the GAIGI process was investigated through a systematic experimental study for tertiary recovery of waterflood residual oil. To obtain heterogeneous (in terms of wettability) packings, isolated inclusions of oil-wet consolidated glass beads were embedded in a continuum of unconsolidated water-wet glass beads. Similarly, the heterogeneous porous media exhibiting permeability heterogeneity consisted of large-pore-size isolated regions randomly distributed in a small-pore-size continuum.
Upon waterflooding, significantly higher waterflood residual oil saturation was established in both cases of heterogeneous media in comparison to water-wet homogeneous porous media. The amount of waterflood residual oil varied linearly with the volume fraction of heterogeneities in the packings. Experimental results obtained from tertiary gravity drainage experiments demonstrated that the continuity of water-wet portions of the heterogeneous porous media facilitates the residual oil recovery through the film flow mechanism, provided that the oil spreading coefficient is positive. In addition, owing to the high waterflood residual oil content of the heterogeneous media tested, the oil bank formation occurred earlier and grew faster than that in homogeneous media, resulting in a higher oil recovery factor. However, the favorable wettability conditions in both the homogeneous and heterogeneous porous media exhibiting permeability heterogeneity resulted in slightly lower reduced residual oil saturation after the GAIGI process compared to that in the heterogeneous media with wettability heterogeneity under the same condition of withdrawal rate. In addition, the oil recovery factor at gas breakthrough was found to be inversely related to the production rate due to the functionality of gravity and viscous forces over the course of gravity drainage. These two forces were combined into a dimensionless form, defined as the gravity number (Ngv=Kogg/oVpg). It was discovered that there is a correlation between the oil recovery factor at gas breakthrough and the gravity number for both the heterogeneous and homogeneous media. The correlation of recovery factor at gas breakthrough versus the gravity number in heterogeneous media followed a similar trend as that found for homogeneous water-wet porous media. However, at a given gravity number, the recovery factor in heterogeneous media was greater than that in the homogeneous media. This implies that heterogeneous media will be better target reservoirs for applying the GAIGI process compared to the homogeneous reservoirs.
| Identifer | oai:union.ndltd.org:WATERLOO/oai:uwspace.uwaterloo.ca:10012/6466 |
| Date | 20 December 2011 |
| Creators | Parsaei, Rafat |
| Source Sets | University of Waterloo Electronic Theses Repository |
| Language | English |
| Detected Language | English |
| Type | Thesis or Dissertation |
Page generated in 0.0129 seconds