The application of high rate algal ponds (HRAP) in the treatment of brewery effluent that met the South African Department of Water Affairs and Forestry's (DWAF) general limits for discharge into a natural water resource of 1998 were tested during a lO-month baseline phase, followed by an 11-month optimization phase. The objective of the baseline phase was to monitor the seasonal performance of HRAPs. The hydraulic retention time (HRT) fluctuated between 11.16 d and 12.00 d in HRAPs. The chemical oxygen demand (COD) increased from 130.12 ± 6.94 mg/L (post-AD), to 171.21 ± 7.99 mg/L (post-HRAP) . The presence of algal cells and evaporation contributed towards an increase in post-HRAP COD. The ammonia (NH₄-N) concentration decreased from 46.59 ± 2.47 mg/L (post-AD), to 1.08 ± 0.12 mg/L (post-HRAP). The nitrite (NO₂- N) concentration remained below 1.00 mg/L in post-pilot plant AD, post-PFP and post-HRAP effluent. The phosphate (PO₄-P) concentration decreased from 29.81 ± 1.39 mg/L (post-AD) to 17.30 ± 1.16 mg/L PO₄-P. The objective of the optimization phase was to manipulate the HRT to achieve the maximum treatment rate that met the DWAF general limits for discharge into a natural water resource of 1998. Nitrogen (as NH₄-N, NO₃-N, NO₂-N) removal efficiency was used as an indicator of nutrient removal success. HRT was influenced by season. The optimal HRT for autumn was 4.30 d at a temperature of 20.53ºC in HRAP A2 (heated) and 18.96ºC in HRAP B2 (ambient). The optimal HRT for summer was 2.74 d at 29.90ºC in HRAP A2 (heated) and 26.36ºC in HRAP B2 (ambient). The COD decreased from 152.33 ± 4.85 mg/L (post-AD) to 95 .00 ± 3.75 mg/L (post-HRAP A2), and to 100.82 ± 5.93 mg/L (post-HRAP B2). The incoming NH₄-N concentration decreased from 42.53 ± 1.38 mg/ L (post-AD), to 1.70 ± 0.81 mg/ L (post-HRAP) . The nitrate (NO₃-N) concentration post-HRAP was 12 - 14 mg/L. The main methods for NH₄-N removal were probably NH₄-N volatilization through algal uptake. HRAPs were able to lower nitrogen and phosphorous concentrations to within the DWAF limits under normal operating conditions. It is recommended that HRAP treated brewery wastewater be used for irrigation after salt removal, or alternatively, for groundwater recharge . Regulatory exemptions would be required for higher than permitted COD and EC concentrations to enable these actions.
| Identifer | oai:union.ndltd.org:netd.ac.za/oai:union.ndltd.org:rhodes/vital:5331 |
| Date | January 2012 |
| Creators | Cilliers, Anneke |
| Publisher | Rhodes University, Faculty of Science, Ichthyology and Fisheries Science |
| Source Sets | South African National ETD Portal |
| Language | English |
| Detected Language | English |
| Type | Thesis, Masters, MSc |
| Format | 160 p., pdf |
| Rights | Cilliers, Anneke |
Page generated in 0.002 seconds