The requirement to operate vehicles in low light and/or night environments whilst wearing night vision goggle (NVG) systems has become increasingly common during military operations. There is very limited research investigating injury risks associated with these systems during ground vehicle collisions. This study examined the injury risks associated with wearing the Australian Defence Force - Enhanced Combat Helmet (ECH) and NVG system, in frontal vehicle collisions. This project consisted of two components: (1) crash tests using a sled and (2) numerical simulations of impacts. Four dynamic sled tests were conducted using a 50th percentile, male, Hybrid III dummy positioned on a rigid seat. Frontal impact tests were performed at a 40 km/h change in velocity (*v) and 20 g deceleration. The test configurations were as follows: (a) Base; (no helmet or additional equipment); (b) ECH; and, (c) ECH and NVG. Condition (c) was carried out twice, to determine repeatability. The sled test protocols were reconstructed precisely with the numerical simulation package MADYMO and the simulations were shown to correlate well with the experimental results. Using this validated model, four parametric studies were undertaken to assess the influence of counterweights, seat cushion, seatbelt pre-tensioner, and the vehicle's *v and acceleration on injury risks. The study found that neck loads were within acceptable limits, with the exception of the neck extension moment, which was exceeded for all NVG conditions. Based on the parametric studies, no major improvements were observed in the neck extension moments with the use of counterweights or a seat cushion. In contrast the use of a seatbelt pre-tensioner was observed to decrease greatly this neck injury risk in certain scenarios. The study also identified that a *v of 15 km/h and peak acceleration of up to 14 g were required to keep the neck extension moment below the prescribed injury criteria. However, the high neck extension moment values may have been partially attributable to the stiff Hybrid III neck. This study identified a possible injury mechanism for soldiers using the ECH and NVG system during specific impact scenarios. The method applied in this project was designed to be repeatable.

The requirement to operate vehicles in low light and/or night environments whilst wearing night vision goggle (NVG) systems has become increasingly common during military operations. There is very limited research investigating injury risks associated with these systems during ground vehicle collisions. This study examined the injury risks associated with wearing the Australian Defence Force - Enhanced Combat Helmet (ECH) and NVG system, in frontal vehicle collisions. This project consisted of two components: (1) crash tests using a sled and (2) numerical simulations of impacts. Four dynamic sled tests were conducted using a 50th percentile, male, Hybrid III dummy positioned on a rigid seat. Frontal impact tests were performed at a 40 km/h change in velocity (*v) and 20 g deceleration. The test configurations were as follows: (a) Base; (no helmet or additional equipment); (b) ECH; and, (c) ECH and NVG. Condition (c) was carried out twice, to determine repeatability. The sled test protocols were reconstructed precisely with the numerical simulation package MADYMO and the simulations were shown to correlate well with the experimental results. Using this validated model, four parametric studies were undertaken to assess the influence of counterweights, seat cushion, seatbelt pre-tensioner, and the vehicle's *v and acceleration on injury risks. The study found that neck loads were within acceptable limits, with the exception of the neck extension moment, which was exceeded for all NVG conditions. Based on the parametric studies, no major improvements were observed in the neck extension moments with the use of counterweights or a seat cushion. In contrast the use of a seatbelt pre-tensioner was observed to decrease greatly this neck injury risk in certain scenarios. The study also identified that a *v of 15 km/h and peak acceleration of up to 14 g were required to keep the neck extension moment below the prescribed injury criteria. However, the high neck extension moment values may have been partially attributable to the stiff Hybrid III neck. This study identified a possible injury mechanism for soldiers using the ECH and NVG system during specific impact scenarios. The method applied in this project was designed to be repeatable.