High output commercial nurseries that cater for the forestry industry are continuously challenged to efficiently and cost effectively produce good quality planting stock to establish large plantations. Currently, South African commercial nurseries produce planting stock in solid compartmentalized trays. One of the major drawbacks of these containers is the susceptibility of trees to root deformation following outplanting, combined with the need for the return of empty containers to the nursery. A potential solution to these challenges is the introduction of wall-less plugs for the production of planting stock. Wall-less plugs are volumes of growing medium, usually cylindrical in shape, devoid of an impenetrable wall in which a plant can grow and establish itself. Such plugs may enable the production of planting stock with improved root systems, without the need for the return of empty containers after outplanting. In this research four prototypes of wall-less plugs were developed, produced on a small scale and tested. These were: 1) Paper-maché plugs made using the original WRIBLOK protocol whereby composted pine bark was bound together with repulped newspaper, 2) Sponge blocks, 3) Hessian bags and 4) Covetan bags. The performance of these prototype wall-less plugs was compared with the performance of four tray types used commercially by the forestry industry: 1) Poly 128 shallow, 2) Poly 98 deep, 3) Unigro 128 and 4) Sappi 49. These are polystyrene and polypropylene-based containers. Of these containers the Unigro 128 and Sappi 49 containers were of similar performance. Performance in terms of height and root collar diameter increase over ten weeks from the time of sowing of the paper-maché plugs was similar to that of the Unigro and Sappi 49 containers. The sponge block, Hessian bags and Covetan bags produced inferior quality planting stock compared to the other treatments tested. Although little progress was made in the ability to describe how one root system differs from another in terms of their branching patterns, a technique was developed to determine root surface area by image analysis software that is freely available. This method may prove useful for further research and for determining seedling quality in commercial nurseries. / Thesis (M.Sc.Agric.)-University of KwaZulu-Natal, Pietermaritzburg, 2011.

The overall aim of the study was to investigate re-vegetation of disturbed sites, using nursery grown plugs (from seedling trays) of Themeda triandra, Heteropogon contortus and Hyparrhenia dregeana in order to reach practical management guidelines for re-vegetation using indigenous grass plugs. A number of field trials were set up at Kamberg Nature Reserve (29°24'S, 29°40'E) on a site that was clear felled of A. mearnsii in October 1997. The trials were established in January 1998 and January 1999. A total of approximately 52 ,000 nursery raised plugs of T. triandra, H. contortus and H. dregeana were planted into an area of approximately 7,000 m2 . In the planting density trial , plugs of H. dregeana only and a combination of T. triandra/H. contortus were planted at 15 cm and 30 cm spacings. The T. triandra/H. contortus combination at 30 spacing showed the greatest survival and lateral plant growth (tiller number and basal area) and this combination is thus recommended. In the over-sowing trials, the H. dregeana and T. triandra/H. contortus combination at both 15 cm and 30 cm spacing were over-sown with E. curvula. The survival and lateral growth of the T. triandra/ H. contortus combination at 30 cm was again greater than the other treatments. Over-sowing with E. curvula suppressed the survival and lateral growth of the planted plugs across all treatments compared to not over-sowing. The over-sown conditions showed a significant decrease in the diversity of the plots, both in the number of species present and the Shannon diversity index. An area that had been cleared of A. mearnsii and sown to E. curvula 25 years previously was shown to have a lower number of species than the neighbouring veld. Nursery raised plugs of T. triandra were planted into the mature E. curvula in an attempt to improve the biodiversity of these areas. To re-introduce T. triandra into these E. curvula swards the plugs must be planted into the centre of a gap rather than around the base of an E. curvula plant. For improved survival of the plugs the E. curvula tufts must be clipped, while for best lateral growth the E. curvula tufts must be sprayed with a glyphosate herbicide three months prior to planting and clipping. However, the added expense of spraying and clipping is not warranted as the clipped treatments also showed good growth. Transplant shock is common when planting nursery raised plugs out into the field, as there is a relatively small root volume in the plug compared to the above ground leaf biomass. Alleviation of moisture stress at planting using a starch based polymer with high water holding capacity (Terrasorb®) and a white, needle punched geo-fabric (Agrilen®) to provide a seven day period of artificial shade after planting did not show significant improvements over the control with regards to survival or plant growth. Thus these methods of moisture amelioration are not recommended in revegetation through planting of plugs at this study site. A trial was established to investigate the biomass production of six different treatments to determine their potential to support a fire. The total biomass for the plots which were over-sown by E. tef and planted to only H. dregeana were on average sufficient for a fire, but there was a discontinuous fuel load across these plots, especially in the replications that had very low survival rates and thus these plots could not be burnt. The control and herbicide sprayed plots also showed sufficient fuel load for a fire, but this fuel load was made up of A. mearnsii saplings and bramble with very little grass cover and thus a fire would not have burnt through these plots either. The T. triandra/H. contortus combination did not produce sufficient fuel load, due to poor survival. Thus only the plots over-sown with E. curvula were able to burn in this trial and as a burning trial per se the trial was abandoned. Seed bearing hay (thatch) was collected in early summer (December 1997) and late summer (April 1998). Both times of year of harvesting proved to be successful in terms of grass cover, although the early harvested thatch had a greater number of species per plot. The Shannon diversity indexes of the two treatments were not significantly different. The multi-response permutation procedure technique confirmed that there was a compositional difference between the treatments. By the end of the trial Harpochloa falx and T. triandra and H. dregeana were indicators for the early and the late harvested thatch respectively. Comparing the thatching trial and the planting density trial indicated that the T. triandra/H. contortus combination at 30 cm spacing would be recommended to maximize biodiversity. The summer months have been shown to be the best time to plant the plugs, although the actual success will be dependant on the conditions within a particular year. The plugs should not be kept in the nursery for longer than three months and larger plugs (96 seedlings per tray) should be used. Nursery raised plugs of T. triandra and H. contortus were planted in an equal mix in an area that was cleared of A. mearnsii in 1996. By June 1998 661 H. contortus seedlings and 14 T. triandra seedlings had germinated naturally. The November 1998 population consisted of 418 H. contortus seedlings and 18 T. triandra seedlings. By May 2000 the June 1998 population showed a survival of 78.4% and the November 1998 population showed a survival of 91 .1 %. In the various trials, the ability of the nursery raised plugs used for re-vegetation to suppress the regrowth of A. mearnsii was investigated by determining the number of A. mearnsii seedlings per metre squared. The plant spacing and species of plugs used did not have a significant effect on the number of A. mearnsii seedlings per metre squared. Over-sowing with E. curvula did, however, significantly suppress the wattle re-growth. In the thatching trial the early harvested plots showed lower numbers of A. mearnsii per metre squared than the late harvest plots, as they were covered with a thick layer of thatch soon after the A. mearnsii was cleared which suppressed the A. mearnsii re-growth. Although E. curvula is able to produce a high biomass and suppress the A. meansii seedlings, it has a detrimental effect on the biodiversity of the area. Therefore, in conservation areas, where biodiversity is of great importance the planted plugs (at 30 cm spacing) or seed bearing hay must be used in preference to sowing E. curvula , although it must be remembered that greater follow up control is likely to be needed with planted plugs or seed bearing hay. The area must be planted or thatched as soon as possible after clear felling to provide competition for the A. mearnsii seedlings. / Thesis (M.Sc.Agric.)-University of KwaZulu-Natal, Pietermaritzburg, 2005.