The work presented herein focuses on expanding the use of CO2-triggered switchable surfactants in emulsion polymerization of hydrophobic and hydrophilic
monomers. Bicarbonate salts of the following compounds were employed as surfactants in the emulsion polymerization of styrene, methyl methacrylate (MMA) and/or butyl methacrylate (BMA): N’-hexadecyl-N,N-dimethylacetamidine (1a), N’-dodecyl N,N-dimethylacetamidine (2a) and N’-(4-decylphenyl)-N,N-dimethylacetamidine (3a). A systematic study of the effects of surfactant and initiator concentrations and solids
content on the resulting particle size and ζ-potential was carried out, showing that a wide range of particle sizes (40 – 470 nm) can be obtained. It was found that as the basicity of the surfactant decreased, the particle size generated from emulsion polymerization increased. Destabilization of these latexes did not require the addition of salts and was carried out using only non-acidic gases and heat. It was shown that solids content,
temperature, particle size and surfactant basicity greatly affect the rate of destabilization of latexes. The area occupied by N’-dodecyl-N,N-dimethylacetamidinium acetate on PMMA particles was determined to be 104 Å2. The monomer-D2O partition coefficient of 2a was determined to be 21 for styrene and 2.2 for MMA. The monomer-D2O partition coefficient of the bicarbonate salt of 2a was determined to be 1.2 for styrene and
0.85 for MMA. An initial assessment of the use of switchable surfactants in the generation of inverse emulsions was carried out. It was determined that butylated polyethyleneimine (BPEI) can successfully stabilize inverse emulsions of cyclohexane and aqueous 2-(dimethylamino)ethyl methacrylate. Upon CO2 introduction, this emulsion separates into two distinct phases. / Thesis (Master, Chemistry) -- Queen's University, 2011-09-26 11:10:14.053
| Identifer | oai:union.ndltd.org:LACETR/oai:collectionscanada.gc.ca:OKQ.1974/6753 |
| Date | 26 September 2011 |
| Creators | FOWLER, CANDACE IRENE |
| Contributors | Queen's University (Kingston, Ont.). Theses (Queen's University (Kingston, Ont.)) |
| Source Sets | Library and Archives Canada ETDs Repository / Centre d'archives des thèses électroniques de Bibliothèque et Archives Canada |
| Language | English, English |
| Detected Language | English |
| Type | Thesis |
| Rights | This publication is made available by the authority of the copyright owner solely for the purpose of private study and research and may not be copied or reproduced except as permitted by the copyright laws without written authority from the copyright owner. |
| Relation | Canadian theses |
Page generated in 0.0016 seconds