It has been debated that among all the renewable energy alternatives, only solar energy offers sufficient resources to meet energy demands. Silicon thin film solar cells are at the frontier of commercial solar technology. Hot wire chemical vapour deposition (HWCVD) is the technique of choice for silicon thin film deposition due to the absence of ion bombardment and its independence toward geometry or electromagnetic properties of the substrate, as seen by plasma enhanced chemical vapour deposition (PECVD). With the implementation of nanostructures in a
multi-band gap tandem solar cell, considerable improvement has been achieved over the single junction solar cells. Defect assisted tunnelling processes at the junctions between individual solar cells in a tandem structure solar cell largely affect the efficiency of these solar cells. In this contribution, the investigation toward the improvement of silicon thin films for tandem solar cell application is initiated. This study reports on the effects of hydrogen dilution and deposition time on six silicon thin films deposited at six specific deposition regimes. The thin film properties are investigated via X-Ray diffraction analysis, Raman spectroscopy, Fourier transform infra-red spectroscopy, elastic recoil detection analysis, scanning and transmission electron microscopy and UV-visible spectroscopy. This investigation revealed the dominating etching effect of atomic hydrogen with
the increase in hydrogen dilution and a bonded hydrogen content (CH) exceeding 10 at.% for each of the six thin films. The optically determined void volume fraction and static refractive index remain constant, for each thin film, with the change in CH. A new deposition procedure, utilising the deposition conditions of the previously investigated thin films, is performed by HWCVD to deposit two silicon thin films. This deposition procedure involved either increasing (protocol 1) or decreasing (protocol 2) hydrogen dilution during deposition. Structural and optical variation with depth was observed for the dynamically deposited silicon thin films, with nano-voids existing across the entire cross section and bond angle variations which are indicative of good structural order. The optical absorption curves differ for the two silicon thin films whereas the optical density remains constant for both. / >Magister Scientiae - MSc
| Identifer | oai:union.ndltd.org:netd.ac.za/oai:union.ndltd.org:uwc/oai:etd.uwc.ac.za:11394/3813 |
| Date | January 2013 |
| Creators | Towfie, Nazley |
| Contributors | Arendse, C. J., Muller, T. F. G., Malgas, G. |
| Source Sets | South African National ETD Portal |
| Language | English |
| Detected Language | English |
| Rights | uwc |
Page generated in 0.0022 seconds