Nanoparticles (NPs) have attracted considerable attention in the field of separation science, especially in filtration studies for direct membrane integrity tests, investigating pore-size distribution, and their potential to be used as surrogates for various types of viruses encountered in water treatment and bioprocessing applications. Although the effect of adding surfactants to stabilize NP suspension have been explored for a number of different applications, there is significant variation in the amounts and types of surfactants used in filtration studies. This study used three different sizes (59, 188, and 490 nm) of fluorescent polystyrene nanoparticles (PNPs) to mimic the length, width, and aggregates of Rhabdovirus Maraba, a bullet-shape envelope virus. The PNPs were suspended in solutions with varying concentrations of the nonionic surfactant Tween 20 (0.0005% to 0.1% (v/v) in the carbonate buffer feed solution) and were tested in constant-flux filtration studies using two commercial microfiltration (MF) membranes (Durapore PVDF and MiniSart PES) with 0.22 micron pore size ratings. Results clearly demonstrate that adding a nonionic surfactant to a PNP solution will cause a shift from full retention to complete transmission during the dead-end MF of PNPs that are smaller than the pore size of an MF membrane. In a separate study, in order to have a better resemblance of virus particles in terms of surface properties, 188 nm PNPs were coated with different (lysozyme, α -lactalbumin and bovine serum albumin) proteins in order to gain similar surface properties to actual virus particles. Filtration results with one type of commercial MF membranes (Durapore PVDF) 0.22 μm pore size, clearly indicate that the transmission behavior of PNPs strongly depends on their surface properties. PNPs fully covered with BSA and α–lactalbumin could completely pass through the membranes while uncovered or partially covered PNPs resulted in no transmission or partial transmission. / Thesis / Master of Applied Science (MASc) / Nanoparticles (NPs) has been employed enormously in various applications for a variety of purposes. One of the areas that have been greatly influenced by NPs, is the field of separation science. In the pharmaceutical industry, purification of therapeutics involves a sequence of filtration and in this step, therapeutic virus filtration, sterile filtration, in particular, have been poorly studied. There is also a growing interest in the use of engineered viruses for cancer treatment due to its magnificent implication on human health. However, there are significant challenges in running filtration experiments with pathogenic substances. Therefore it has been determined that a detailed and comprehensive study of sterile filtration of virus-size NPs can benefit this area. In this work, fluorescently-labeled NPs has been used as surrogates of oncolytic viruses to extract fundamental aspects affecting the transmission of virus-sized particles through commercial microfiltration sterilizing grade membranes.
| Identifer | oai:union.ndltd.org:mcmaster.ca/oai:macsphere.mcmaster.ca:11375/24021 |
| Date | January 2018 |
| Creators | Pazouki, Mohammadreza |
| Contributors | Latulippe, David, Chemical Engineering |
| Source Sets | McMaster University |
| Language | English |
| Detected Language | English |
| Type | Thesis |
Page generated in 0.0017 seconds