The resonance frequency of a silicon nitride (SiN) nano-electromechanical systems (MEMS/NEMS) can be measured precisely due to their large quality factor that is associated to low thermomechanical fluctuations. While these properties enable the fabrication of high performance sensors, their use will eventually raise questions regarding their long-term stability, notably for calibration purposes. The long-term frequency stability and aging of SiN are less studied than the short-term fluctuations such as thermomechanical noise. Long-term aging studies exist for quartz clocks as well as MEMS silicon clocks and accelerometers, but not for SiN resonators with high quality factors. Thus, in this work we conduct the aging study of SiN membranes fabricated by our lab, by constantly tracking changes of the resonance frequency of the device over a long period. The evolution of the frequency drift is tracked, by optical interrogation, continuously for 135 days with a digital phase locked loop (PLL). Our device is placed in a cell under high vacuum to suppress air damping on our resonating membrane. Furthermore, due to its high sensitivity to temperature changes, our silicon nitride resonator and vacuum chamber are placed in an air bath providing a stable temperature (within 0.5 K over 135 days in the present case). To compensate further the frequency drifts induced by temperature changes, a multimeter measures the resistance of a calibrated thermistor placed inside the vacuum environment. The measured frequency drift for the aging periods of 135 days was of 300 parts per million (ppm) and was consistent with previously reported double logarithmic models for quartz oscillators. The initial stage of negative frequency drift, in our aging data, is consistent with the behaviour expected from the desorption of water due to the transition from ambient air environment to high vacuum. We review models explaining how water adsorption/desorption impacts our membrane's frequency by (1) inducing chemical reaction stresses (most important effect), (2) through the contribution of the water surface tension stress (non-negligible effect), and (3) through mass loading from water molecules (weakest effect). After this initial negative trend, the membrane frequency drift inverts and increases almost linearly, in a fashion consistent with loss of mass from desorption of other chemical species. To identify these chemical species, X-ray photoelectron spectroscopy measurements were conducted on a reference membrane stored in an ambient setting and on our membrane placed under vacuum during our aging studies. The aged membrane, compared to its reference counterpart, contained substantially less alkaline ion contaminants (i.e., sodium, calcium and potassium), most likely due to desorption of these species during the aging measurement, and to the increase in adsorption occurring on the reference membrane concurrently. We therefore hypothesize that trapped negative charges, which is a typical phenomenon within dielectric materials such as SiN, might progressively attract positive ion contaminants over time when the device is exposed to ambient air.
| Identifer | oai:union.ndltd.org:uottawa.ca/oai:ruor.uottawa.ca:10393/45306 |
| Date | 21 August 2023 |
| Creators | Stephan, Michel |
| Contributors | St-Gelais, Raphael |
| Publisher | Université d'Ottawa / University of Ottawa |
| Source Sets | Université d’Ottawa |
| Language | English |
| Detected Language | English |
| Type | Thesis |
| Format | application/pdf |
| Rights | Attribution-NonCommercial-NoDerivatives 4.0 International, http://creativecommons.org/licenses/by-nc-nd/4.0/ |
Page generated in 0.0025 seconds