The objective of this research was to assess the condition of four decommissioned bridge decks treated with waterproofing membranes and asphalt overlays following the completion of their service lives. Large samples were cut from each of the bridge decks immediately prior to demolition and taken to the Brigham Young University Highway Materials Laboratory, where extensive sampling and testing was performed. Methods used to evaluate the condition of the bridge deck samples included visual inspection, hammer sounding, Schmidt rebound hammer testing, resistivity testing, half-cell potential testing, linear polarization testing, cover depth measurement, and chloride concentration measurement. The samples were removed from four concrete bridge decks along the Interstate 15 corridor in Provo, Utah. One bridge deck was constructed in 1937, two were constructed in 1964, and one was constructed in 1984. Each of the bridge decks was constructed using conventional cast-in-place methods. With the exception of the 1984 bridge deck, which had epoxy-coated rebar, all of the bridge decks were reinforced with black bar. A waterproofing membrane was installed on each of the bridge decks in 1984, meaning each waterproofing membrane had been in service for 26 or 27 years at the time of sampling. With the exception of one of the bridges, which was in good condition after 26 years of service, each of the bridge decks sampled had successfully served for at least 46 years. Aside from asphalt maintenance, no rehabilitation was needed on any of the bridge decks following installation of the waterproofing membranes. Without the application of the waterproofing membranes, the chloride concentrations in the bridge decks likely would have been much higher. Additional exposure to chloride ions from deicing salts would have quickly increased the chloride concentration in the concrete above critical levels, which would have led to significant corrosion and bridge deck deterioration, prematurely. While the application of membranes as a bridge deck maintenance procedure has mostly been replaced by the use of epoxy-based polymer overlays, many bridge decks protected with membrane systems are still in service today. The research findings suggest that application of waterproofing membranes and asphalt overlays in a timely manner, before the accumulation of excessive amounts of chlorides within a deck, can be an effective approach for concrete bridge deck preservation.

The study of innovative pavements is of significant importance in geotechnical engineering in Brazil, due to the continued need to increase the network of roadways. This requires optimized projects, not only for economic, but also for technical reasons. Technical solutions that use geosynthetics in asphalt overlays have been identified to minimize fatigue and reflective cracks. However, the majority of the application of this technology has ignored the possible additional structural benefits brought by the inclusion of geosynthetics as reinforcement in asphalt layers. The objective of this research is to assess the reinforcement benefits of geogrids placed within asphalt overlays on the structural performance of flexible pavements. In addition, this study investigates the tensile-strain response of geogrids under traffic conditions, induced by cyclic wheel loads generated by a new accelerated pavement testing facility (APT) that was specifically developed for this research. The APT facility consists of a large steel testing box, in which field-scale pavement layers could be constructed. Pavement materials included subgrade soil, aggregate base, hot mix asphalt concrete, asphalt emulsion and a PVA geogrid. Pavement performance was assessed by applying a cyclic wheel load pressure of 700 kPa to the pavement surface. The pavement sections investigated in this study included a geogrid-reinforced and an unreinforced asphalt overlay sections, a single new geogrid-reinforced asphalt layer, and a geogrid-reinforced asphalt overlay with reduced base course thickness. A variety of sensors were used to measure asphalt concrete strains, surface plastic and elastic displacements, and induced traffic loads. Displacements along the geogrid specimens were measured using a tell-tail system. As result, several reinforcement mechanisms of this technique could be quantified in the present study. Polymeric geogrid reinforcements were found to have considerably reduced strains developed at the bottom of asphalt layers, as well as to have reduced vertical stresses in pavement lower layers. Resistance to rutting and lateral movement induced by the geogrids were also clearly evidenced in the presented study. The measurement of displacements along the geogrid provided understanding of the distribution of strains during traffic loading. A mobilized length was identified in geogrid-reinforced sections, showing that the bonding between geogrids and asphalt layers and the stiffness of the geogrid ensured satisfactory performance of the pavement sections. The results also illustrated that the lateral restraining mechanisms effect is a governing mechanism to improve the performance of the asphalt layers by the development of shearing resistance with the geogrids. Overall, it was concluded that geogrids within asphalt overlays act as reinforcement and not merely to delay cracks, providing enhanced performance to flexible pavement structures. / O estudo de pavimentos é de grande importância na Engenharia Geotécnica brasileira devido à crescente necessidade de melhora da situação da rede rodoviária nacional. Para tanto, o desenvolvimento e a aplicação de novas técnicas são necessários, principalmente no âmbito econômico. A técnica do uso de reforços geossintéticos em capa asfáltica é identificada como uma alternativa ao aumento da vida útil do pavimento através da mitigação de trincas por fadiga e de reflexão. No entanto, a maioria das aplicações desta técnica não correlaciona os benefícios estruturais da inclusão do geossintético na capa asfáltica para a melhora do desempenho global do pavimento. O objetivo desta pesquisa é investigar os benefícios estruturais no desempenho de pavimentos flexíveis trazidos pelo reforço de geogrelhas em camadas asfálticas. Ainda neste estudo, será investigada a reposta tensão-deformação destas geogrelhas sobre as condições de tráfego através do uso de ensaios acelerados de pavimento. Um equipamento foi desenvolvido para esta pesquisa e consiste numa caixa metálica de grande porte, em que seções de pavimento em escala real podem ser construídas. O desempenho das seções de pavimento foi avaliado com a aplicação de cargas cíclicas de roda com pressão de contato de 700 kPa. Os materiais que compõem as seções de pavimento incluem solo de subleito, brita graduada simples, concreto betuminoso usinado à quente, emulsão asfáltica e geogrelha de PVA. Foram estudadas uma seção com geogrelha como reforço no recapeamento da camada asfáltica, uma seção idêntica não reforçada, uma seção com uma única capa asfáltica reforçada com geogrelha e uma seção com geogrelha no recapeamento da camada asfáltica, porém com espessura de base reduzida em relação aos demais ensaios. Sensores nas camadas do pavimento mediram tensões e deformações, e deslocamentos plásticos e elásticos na superfície. Deslocamentos ao longo da geogrelha foram monitorados utilizando o sistema tell-tales. Como resultado, mecanismos de reforço foram identificados neste estudo. O uso de uma geogrelha polimérica reduziu consideravelmente as deformações na fibra inferior da capa asfáltica, assim como as tensões verticais nas camadas subjacentes do pavimento. Resistência à formação de trilhas de roda e solevamentos laterais foram também evidenciadas. As medidas de deslocamentos ao longo da geogrelha forneceram entendimento da distribuição de deformações durante o carregamento. Foi identificado o comprimento de geogrelha mobilizado durante os ensaios, mostrando que a aderência entre a geogrelha e as camadas asfálticas e a rigidez da geogrelha asseguraram o desempenho satisfatório das seções de pavimento. Os resultados também mostraram que o efeito do mecanismo de restrição lateral é um mecanismo que governa a melhora no desempenho da capa asfáltica com o uso da geogrelha através do desenvolvimento de resitência ao cisalhamento. Estas observações permitem concluir que a geogrelha na camada asfáltica atua como reforço e não apenas reduzindo a o potencial de trincamento, levando à um aumento no desempenho de estruturas de pavimentos flexíveis.

This research project, funded by the Federal Highway Administration, entails the construction of an outdoor exposure site in order to evaluate various methods for mitigating alkali-silica reaction (ASR) in hardened concrete. The exposure site, built at the Concrete Durability Center at the University of Texas at Austin J.J. Pickle Research campus, included a series of bridge deck, column and slab elements. The specimens were cast in 2008, allowed to expand to predetermined expansion levels and then treated with various mitigation measures, after which the specimens were monitored for expansion, humidity, and deterioration. / text

The study of innovative pavements is of significant importance in geotechnical engineering in Brazil, due to the continued need to increase the network of roadways. This requires optimized projects, not only for economic, but also for technical reasons. Technical solutions that use geosynthetics in asphalt overlays have been identified to minimize fatigue and reflective cracks. However, the majority of the application of this technology has ignored the possible additional structural benefits brought by the inclusion of geosynthetics as reinforcement in asphalt layers. The objective of this research is to assess the reinforcement benefits of geogrids placed within asphalt overlays on the structural performance of flexible pavements. In addition, this study investigates the tensile-strain response of geogrids under traffic conditions, induced by cyclic wheel loads generated by a new accelerated pavement testing facility (APT) that was specifically developed for this research. The APT facility consists of a large steel testing box, in which field-scale pavement layers could be constructed. Pavement materials included subgrade soil, aggregate base, hot mix asphalt concrete, asphalt emulsion and a PVA geogrid. Pavement performance was assessed by applying a cyclic wheel load pressure of 700 kPa to the pavement surface. The pavement sections investigated in this study included a geogrid-reinforced and an unreinforced asphalt overlay sections, a single new geogrid-reinforced asphalt layer, and a geogrid-reinforced asphalt overlay with reduced base course thickness. A variety of sensors were used to measure asphalt concrete strains, surface plastic and elastic displacements, and induced traffic loads. Displacements along the geogrid specimens were measured using a tell-tail system. As result, several reinforcement mechanisms of this technique could be quantified in the present study. Polymeric geogrid reinforcements were found to have considerably reduced strains developed at the bottom of asphalt layers, as well as to have reduced vertical stresses in pavement lower layers. Resistance to rutting and lateral movement induced by the geogrids were also clearly evidenced in the presented study. The measurement of displacements along the geogrid provided understanding of the distribution of strains during traffic loading. A mobilized length was identified in geogrid-reinforced sections, showing that the bonding between geogrids and asphalt layers and the stiffness of the geogrid ensured satisfactory performance of the pavement sections. The results also illustrated that the lateral restraining mechanisms effect is a governing mechanism to improve the performance of the asphalt layers by the development of shearing resistance with the geogrids. Overall, it was concluded that geogrids within asphalt overlays act as reinforcement and not merely to delay cracks, providing enhanced performance to flexible pavement structures. / O estudo de pavimentos é de grande importância na Engenharia Geotécnica brasileira devido à crescente necessidade de melhora da situação da rede rodoviária nacional. Para tanto, o desenvolvimento e a aplicação de novas técnicas são necessários, principalmente no âmbito econômico. A técnica do uso de reforços geossintéticos em capa asfáltica é identificada como uma alternativa ao aumento da vida útil do pavimento através da mitigação de trincas por fadiga e de reflexão. No entanto, a maioria das aplicações desta técnica não correlaciona os benefícios estruturais da inclusão do geossintético na capa asfáltica para a melhora do desempenho global do pavimento. O objetivo desta pesquisa é investigar os benefícios estruturais no desempenho de pavimentos flexíveis trazidos pelo reforço de geogrelhas em camadas asfálticas. Ainda neste estudo, será investigada a reposta tensão-deformação destas geogrelhas sobre as condições de tráfego através do uso de ensaios acelerados de pavimento. Um equipamento foi desenvolvido para esta pesquisa e consiste numa caixa metálica de grande porte, em que seções de pavimento em escala real podem ser construídas. O desempenho das seções de pavimento foi avaliado com a aplicação de cargas cíclicas de roda com pressão de contato de 700 kPa. Os materiais que compõem as seções de pavimento incluem solo de subleito, brita graduada simples, concreto betuminoso usinado à quente, emulsão asfáltica e geogrelha de PVA. Foram estudadas uma seção com geogrelha como reforço no recapeamento da camada asfáltica, uma seção idêntica não reforçada, uma seção com uma única capa asfáltica reforçada com geogrelha e uma seção com geogrelha no recapeamento da camada asfáltica, porém com espessura de base reduzida em relação aos demais ensaios. Sensores nas camadas do pavimento mediram tensões e deformações, e deslocamentos plásticos e elásticos na superfície. Deslocamentos ao longo da geogrelha foram monitorados utilizando o sistema tell-tales. Como resultado, mecanismos de reforço foram identificados neste estudo. O uso de uma geogrelha polimérica reduziu consideravelmente as deformações na fibra inferior da capa asfáltica, assim como as tensões verticais nas camadas subjacentes do pavimento. Resistência à formação de trilhas de roda e solevamentos laterais foram também evidenciadas. As medidas de deslocamentos ao longo da geogrelha forneceram entendimento da distribuição de deformações durante o carregamento. Foi identificado o comprimento de geogrelha mobilizado durante os ensaios, mostrando que a aderência entre a geogrelha e as camadas asfálticas e a rigidez da geogrelha asseguraram o desempenho satisfatório das seções de pavimento. Os resultados também mostraram que o efeito do mecanismo de restrição lateral é um mecanismo que governa a melhora no desempenho da capa asfáltica com o uso da geogrelha através do desenvolvimento de resitência ao cisalhamento. Estas observações permitem concluir que a geogrelha na camada asfáltica atua como reforço e não apenas reduzindo a o potencial de trincamento, levando à um aumento no desempenho de estruturas de pavimentos flexíveis.

Chloride-induced deterioration of concrete bridge decks can be described in terms of three phases: 1) initiation of rebar corrosion, 2) rust formation and development of deck damage, and 3) accelerated deck damage towards structural failure. The first objective of this research was to investigate relationships among chloride concentration at the top mat of reinforcing steel, deck age, cover depth, and occurrence of delamination for concrete bridge decks with selected surface treatments and rebar types. Relating these factors can help establish greater understanding about the duration of each phase of the deterioration process. A second objective of this research was to investigate the relationship between chloride concentrations that develop between the bars and those that develop directly above the bars in the top mat of reinforcing steel to better understand the effects of the presence of reinforcing steel on diffusion of chloride ions through the concrete matrix.Data collected from 48 concrete bridge decks in Utah were used to address both of the objectives stated for this research. Surface treatment types included bare concrete, thin-bonded polymer overlays, and asphalt overlays, and rebar types included uncoated and epoxy-coated rebar. Regarding the first objective, baseline relationships between chloride concentration, deck age, and cover depth were developed for all three deck types. The results show that, as deck age increases, chloride concentration also increases and that chloride concentrations are much higher for shallower concrete depths than for deeper concrete depths. Based on these relationships, the duration of the first phase of the deterioration process was estimated using the critical chloride threshold of 2.0 lb Cl-/yd3 of concrete. For decks with asphalt or polymer overlays, development of clear relationships between chloride concentration, deck age, and cover depth required consideration of treatment time. The data show that chloride concentrations for decks that had an overlay applied 10 or more years after construction are higher than those for decks that had an asphalt overlay applied immediately after construction. Relevant to determining the duration of the second phase of the deterioration process, the relationship between delamination occurrence and chloride concentration for bare concrete bridge decks was developed. In general, the results show that the occurrence of delamination increases with increasing chloride concentration. Estimated durations of the second phase of the deterioration process were then determined using a chloride concentration threshold of 4.0 lb Cl-/yd3 of concrete for each of the same combinations of surface treatment and cover depth used for determining durations of the first phase of the deterioration process. Regarding the performance of epoxy-coated bar, the data clearly demonstrate the benefit of epoxy coatings on reinforcing steel for the purpose of significantly delaying the onset of chloride-induced delamination in concrete bridge decks. The relationship between the ratio of chloride concentrations directly above and between steel reinforcing bars and deck age was then developed. The results show that, as deck age increases, the average ratio of chloride concentrations directly above and between the bars asymptotically decreases from above 1.5 toward 1.0, which is reached at a deck age of approximately 30 years. Given that increasing deck age generally corresponds to increasing chloride concentration, which would in turn eventually lead to similar chloride concentrations directly above and between bars as the concrete pore water within the cover depth approached chloride saturation, this observed relationship is consistent with theory.