Thesis (MSc)--Stellenbosch University, 2012. / ENGLISH ABSTRACT: The yeast Brettanomyces was isolated from beer in 1904 and associated with wine thereafter. A sporulating form, Dekkera, was discovered later. Brettanomyces bruxellensis produces high levels of volatile phenol off-flavours in wine. Sulphur dioxide (SO2) is the most widely used chemical preservative in wine. Yeasts have several mechanisms to cope with the SO2, namely Ssu1p, a membrane bound SO2 transporter; sulphite reduction, sulphite oxidation and acetaldehyde production. In unfavourable environmental conditions, certain yeasts can enter a viable-but-non-culturable (VBNC) state which is characterised by reduced metabolic rate, inability to reproduce on solid media and a reduction of cell size. VBNC can be triggered by chemical stress such as high SO2 levels. The objectives of this study were to examine the SO2 tolerance of B. bruxellensis and Saccharomyces cerevisiae, to quantify their rates of SO2 accumulation and efflux, determine the effect of SO2 on their energy metabolism and investigate if B. bruxellensis possesses an orthologue to S. cerevisiae SSU1. In this study, the identity of a number of Brettanomyces/Dekkera strains was confirmed using 5.8S rDNA-ITS RFLP analysis and DNA sequencing. Sporulation assays were used to confirm whether these strains belonged to the Dekkera or Brettanomyces genus. A method to accurately quantify SO2 in laboratory conditions was optimised. Molecular SO2 tolerance was tested by spotting fresh yeast cultures on media with SO2 and/or ethanol. Tolerance to SO2 and/or ethanol showed highly strain dependent results with S. cerevisiae showing the highest tolerance levels while B. bruxellensis tolerated SO2 and ethanol poorly but certain strains grew well with only SO2. The SO2 accumulation and efflux rates of 3 S. cerevisiae strains and 3 B. bruxellensis strains were determined. It was shown that the S. cerevisiae strains followed the same trends as previously found in literature whereas B. bruxellensis strains showed similar trends but displayed highly variable strain-dependent results. B. bruxellensis CB63 and S. cerevisiae VIN13 were investigated for their response to SO2 in two different media, TA and SWM, over a 48-hour and 32-day period respectively. Acetic acid, acetaldehyde, D-glucose, D-fructose (only in SWM) and ethanol (only in TA) were regularly monitored over the time course of each experiment. SO2 had the greatest impact on B. bruxellensis with decreased rates of glucose consumption and ethanol production as well as increased acetic acid. Acetaldehyde peaked shortly after SO2 addition with the subsequent restarting of sugar consumption for certain samples. This suggests that sufficient acetaldehyde was produced to bind free SO2 to reduce SO2 stress. Volatile phenols were quantified for day 32 of the SWM experiment. An increase of 4-ethyl guaiacol was correlated to higher molecular SO2 levels. SO2 negatively affected both yeasts energy metabolism, forcing the yeasts metabolism to adapt to ensure survival. In general, SO2 was shown to have a negative impact on all aspects of a yeasts growth and metabolism and that SO2 tolerance is highly strain dependent and a far more complicated characteristic than currently understood. / AFRIKAANSE OPSOMMING: Die gis Brettanomyces is in 1904 uit bier geïsoleer en daarna met wyn geassosieer. 'n sporulerende vorm, Dekkera, is later ontdek. Brettanomyces bruxellensis produseer hoë vlakke van vlugtige fenol afgeure in wyn. Swaweldioksied (SO2) is die mees gebruikte chemiese preserveermiddel in wyn. Giste het verskeie meganismes om SO2 te hanteer, naamlik Ssu1p, 'n membraan-gebonde SO2 transporter, sulfietvermindering, sulfiet-oksidasie en asetaldehiedproduksie. In ongunstige omgewingstoestande kan sekere giste 'n lewensvatbare, maar nie-kultiveerbare (LMNK)-toestand aanneem wat gekenmerk word deur verlaagde metaboliese tempo, onvermoë om voort te plant op soliede media en 'n vermindering van die selgrootte. LMNK kan veroorsaak word deur chemiese stres, soos hoë SO2-vlak. Die doelwitte van hierdie studie was om die SO2 -bestandheid van B. bruxellensis en Saccharomyces cerevisiae te ondersoek, hul spoed van SO2 -opneming/akkumulasie en -uitskeiding te kwantifiseer, die invloed van SO2 op energiemetabolisme te bepaal en te ondersoek of B. bruxellensis oor ‘n soortgelyke geen as die S. cerevisiae SSU1 beskik. In hierdie studie is die identiteit van 'n aantal Brettanomyces/Dekkera-stamme bevestig deur 5.8S rDNA-ITS RFLP-analise en DNA-opeenvolging te gebruik. Sporulasietoetse is gebruik om te bevestig of hierdie stamme aan die genus Dekkera of Brettanomyces behoort. 'n Metode om SO2 onder laboratoriumtoestande akkuraat te kwantifiseer, is geoptimiseer. Molekulêre SO2- bestandheid is getoets deur vars giskulture op media met SO2 en/of etanol te groei. Bestandheid teen SO2 en/of etanol het stam-afhanklike resultate getoon, S. cerevisiae wat die hoogste toleransievlakke getoon het, terwyl B. bruxellensis SO2 en etanol swak tolereer, maar sekere stamme het goed gegroei met slegs SO2. Die SO2-akkumulasie en -uitskeidingtempo van 3 S. cerevisiae-rasse en 3 B. bruxellensis-stamme is bepaal. Daar is gevind dat die S. cerevisiae-rasse dieselfde tendens soos voorheen in die literatuur beskryf, gevolg het, terwyl B. bruxellensis-stamme soortgelyke tendense getoon het,maar hoogs veranderlike stamafhanklike resultate vertoon. B. bruxellensis CB63 en S. cerevisiae VIN13 is ondersoek vir hul reaksie tot SO2 in twee verskillende media, TA en SWM, oor 'n tydperk van 48-uur en 32-dae onderskeidelik. Asynsuur, asetaldehied, D-glukose, D-fruktose (slegs in SWM) en etanol (slegs in TA) is gereeld gemoniteer oor die verloop van elke eksperiment. SO2 het die grootste impak op B. bruxellensis met ‘n verlaagde tempo van glukoseverbruik en etanolproduksie, sowel as verhoogde asynsuur. ‘n Asetaldehiedhoogtepunt is bereik kort na die SO2-byvoeging met die daaropvolgende hervatting van suiker wat vir sekere monsters gebruik is. Dit dui daarop dat voldoende asetaldehied geproduseer is om vry SO2 te bind om SO2-stres te verminder. Vlugtige fenole is op dag 32 van die SWM-eksperiment gekwantifiseer. 'n Toename van 4-etiel-guajakol korreleer met hoër molekulêre SO2-vlakke. SO2 het beide giste se energiemetabolisme negatief beïnvloed, wat die gis dwing om sy metabolisme aan te pas om oorlewing te verseker. Oor die algemeen het SO2 'n negatiewe impak op alle aspekte van giste se groei en metabolisme, en SO2-bestandheid is hoogs stam–afhanklik. Dit is ook 'n baie meer ingewikkelde kenmerk as wat tans verstaan word.

Consumption of frozen chicken breaded has increased considerably in recent decades, since they are practical and tasty, able to meet the needs of consumers. The intrinsic characteristics of this product are favorable to the proliferation of pathogenic and spoilage micro -organisms and the application of low temperatures has been the method used to extend the life of these breaded meat. Microbiological contamination can originate in breaded raw material used for production or produced during the handling and processing operations and multiplication of these microorganisms during storage can modify the sensory and nutritional properties of the food, and pose a problem food security. Due to their ability to overcome barriers of temperature and water activity, fungi are the main micro -organisms able to degrade the group of frozen foods, which, besides the appearance and deteriorating economic losses, represents a public health problem by the possibility production of mycotoxins in the product and consumer exposure. The aim of this study was to identify the main species of filamentous fungi involved in the deterioration of frozen chicken breaded , check secondary metabolites produced by the same and assess the growth of the two predominant species when exposed to low temperatures and, in parallel, to determine the temperature at counters freeze 6 supermarkets in the city of Santa Maria - RS. The predominant species involved in the deterioration of frozen chicken breaded were Penicillium glabrum, Penicillium polonicum, Penicillium manginii, Penicillium solitum and Penicillium crustosum. The analysis of the secondary metabolite profile showed the capacity to synthesize mycotoxins as cyclopiazonic acid citroviridina, roquefortina C, penitren A and verrucosidina by some isolates. The results demonstrated that the fungus P. polonicum, was able to form visible colonies on the surface of frozen chicken breaded kept at -5°C for 120 days. For P. glabrum the lowest growth was observed that temperature was 0°C. A ' spot ' supermarkets temperature analysis revealed temperature higher than -5°C in at least one of the time points evaluated, and 4 supermarkets 6 (66%) had at least one peak temperature above 0°C, with a maximum of 9.8 °C. Since there is occurrence of storage temperatures at which frozen foods fungi P. polonicum and P. glabrum could develop and knowing that these species have the ability to produce toxic metabolites, emphasize the need for greater attention to research related to fungal spoilage of frozen foods, source of contamination, methods of prevention and possible implications of the consumption of contaminated for public health products. / O consumo de empanados congelados de frango aumentou consideravelmente nas últimas décadas, uma vez que são produtos práticos e saborosos, capazes de satisfazer as necessidades dos consumidores. As características intrínsecas deste produto são favoráveis à proliferação de micro-organismos patogênicos e deteriorantes e a aplicação de baixas temperaturas tem sido o método mais empregado para prolongar a vida útil destes empanados cárneos congelados. A contaminação microbiológica em empanados pode se originar da matéria-prima utilizada para sua elaboração ou se produz durante a manipulação e operações de processamento e a multiplicação destes micro-organismos durante a estocagem pode modificar as propriedades sensoriais e nutricionais do alimento, além de representar um problema de segurança alimentar. Devido a sua habilidade em superar barreiras de temperatura e atividade de água, os fungos são os principais micro-organismos capazes de deteriorar o grupo dos alimentos congelados, o que, além do aspecto deteriorativo e perdas econômicas, representa um problema de saúde pública pela possibilidade de produção de micotoxinas no produto e exposição do consumidor. O objetivo deste estudo foi de identificar as principais espécies de fungos filamentosos envolvidas na deterioração de empanados congelados de frango, verificar metabólitos secundários produzidos pelas mesmas e avaliar o crescimento das duas espécies predominantes quando expostas à baixas temperaturas e, em paralelo, determinar a temperatura em balcões de congelamento de 6 supermercados da cidade de Santa Maria-RS. As espécies predominantes envolvidas na deterioração de empanados congelados de frango foram Penicillium glabrum, Penicillium polonicum, Penicillium manginii, Penicillium solitum e Penicillium crustosum. A análise do perfil de metabólitos secundários revelou capacidade de síntese de micotoxinas como ácido ciclopiazônico, citroviridina, roquefortina C, penitrem A e verrucosidina por alguns isolados. Os resultados demonstraram que o fungo P. polonicum, foi capaz de formar colônias visíveis na superfície dos empanados congelados de frango conservados à -5°C aos 120 dias. Para P. glabrum a menor temperatura que foi observado crescimento foi 0ºC. A análise in loco da temperatura dos supermercados revelou temperatura superior a -5°C em pelo menos um dos momentos avaliados, sendo que 4 de 6 supermercados (66%) apresentaram pelo menos um pico de temperatura acima de 0 °C, com um máximo de 9,8°C. Visto que há ocorrência de temperaturas de armazenagem de alimentos congelados nas quais os fungos P. polonicum e P. glabrum poderiam se desenvolver e sabendo-se que estas espécies têm a capacidade de produzir metabólitos tóxicos, ressalta-se a necessidade de maior atenção para pesquisas relacionadas a deterioração fúngica de alimentos congelados, origem da contaminação, formas de prevenção e possíveis implicações do consumo de produtos contaminados para a saúde pública.

Made available in DSpace on 2014-06-11T19:27:16Z (GMT). No. of bitstreams: 0 Previous issue date: 2008-06-06Bitstream added on 2014-06-13T19:35:10Z : No. of bitstreams: 1 felipe_lm_me_jabo.pdf: 356871 bytes, checksum: 16d6d5f606db8c2a71fd32fc4c6570dc (MD5) / Coordenação de Aperfeiçoamento de Pessoal de Nível Superior (CAPES) / A deterioração “blown pack” é caracterizada por abundante produção de gás, induzindo a completa distensão da embalagem durante o processo de estocagem sob refrigeração. Quando a embalagem é aberta, há um odor desagradável, levemente fecal. O gás presente na embalagem é composto por dióxido de carbono e hidrogênio e por vários tipos butíricos do metabolismo fermentativo. O objetivo deste experimento foi determinar possíveis causadores deste tipo de deterioração, quantificando as populações de bactérias da família Enterobacteriaceae, e caracterizando-as nos principais gêneros e espécies encontradas, o número de bactérias ácido-lácticas, a freqüência de Clostridium estertheticum e do Clostridium gasigenes, em carnes próprias para o consumo e em carnes que apresentaram a deterioração “blown pack”. Para contagem e identificação dos membros da família Enterobacteriaceae e contagem de bactérias ácido-lácticas utilizou-se de técnicas microbiológicas clássicas. Já para pesquisa do C. estertheticum e C. gasigenes fez-se uso de técnicas de biologia molecular. Os microrganismos da família Enterobacteriaceae e bactérias ácido-láticas estavam presentes em populações elevadas e em maior número nas carnes com deterioração “blown pack”. A espécie mais freqüentemente encontrada foi a Hafnia alvei. As amostras com deterioração “blown pack’ apresentaram maior positividade para o C. estertethicum que amostras não deterioradas. Não houve diferença estatística de positividade para a presença do C. gasigenes entre amostras com deterioração “blown pack” e carnes não deterioradas. A principal forma de controle desta deterioração é a prevenção da contaminação da carne por material fecal. / The blown pack spoilage is characterised by abundant gas production, leading to complete gross distention pack during refrigerated storage. When the packaging is opened, there is an unpleasant smell, lightly fecal. The gas present in the package is composed of carbon dioxide and hydrogen and also of several butyric types of metabolism fermentation. The purpose of this experiment was to determine possible causes of this spoilage type, quantifying the populations of bacteria of the family Enterobacteriaceae, and characterizing them in the major genera and species found, the number of lactic acid bacteria, the frequency of Clostridium estertheticum and Clostridium gasigenes in meat proper for consumption and meat which showed the blown pack spoilage. In order to enumerate and identify the members of the Enterobacteriaceae family, and to enumerate the lactic acid bacteria the procedure was classical microbiological techniques. However to search the C. estertheticum and C. gasigenes the procedure was molecular biology techniques. The microorganisms of the family Enterobacteriaceae and lactic acid bacteria were present in large populations and in greater numbers in meat with blown pack spoilage. The species which were found more often was the Hafnia alvei. Samples of blown pack“ spoilage had greater positive features for C. estertethicum than samples not damaged. There was no statistical difference of positive features for the presence of C. gasigenes between samples of blown pack spoilage and not damaged meat. The main way to control this spoilage is the prevention of contamination of meat by fecal material.

A utilização de embalagens biodegradáveis, tais como os filmes e coberturas comestíveis, apresenta-se como alternativa ao uso de recursos não-renováveis como material de embalagem. A incorporação de substâncias antimicrobianas em embalagens tem como objetivo minimizar o problema da contaminação microbiana em alimentos e, entre elas, os óleos essenciais (OE) têm recebido atenção especial por serem substâncias naturais e atenderem à preferência dos consumidores. Porém, a utilização de OE como um agente antimicrobiano natural é limitada por critérios organolépticos, sendo necessário determinar a concentração mínima necessária para inibir o desenvolvimento de microrganismos sem afetar sensorialmente as características do alimento. Assim, os objetivos desta pesquisa foram: desenvolver um filme comestível à base de alginato com incorporação de agentes antimicrobianos naturais e avaliar a adição de diferentes concentrações de cloreto de cálcio (CaCl2) como agente crosslinking na formulação do filme e na etapa complementar de formação do filme; caracterizar o filme frente às propriedades mecânicas e propriedades de barreira; determinar a concentração mínima inibitória (CIM) de óleos essenciais para Pseudomonas spp., Salmonella spp. e Listeria monocytogenes presentes em carne de frango, e verificar a aceitação pelo consumidor, através da análise sensorial (aroma), de pedaços de peito de frango in natura embalado com o filme antimicrobiano O OE de cravo foi o que se apresentou mais eficiente para os microrganismos testados com CIM de 0,2% sendo este o limite mínimo estudado no planejamento experimental para o desenvolvimento do filme antimicrobiano. As variáveis independentes neste planejamento foram: CaCl2 na faixa de concentração de 0,02 a 0,1% e OE cravo na faixa de 0,2 a 1,0%. Valores acima de 0,0316% de CaCl2, independente da concentração de OE estudada, diminuiram a zona de inibição do crescimento microbiano em testes realizados in vitro, possivelmente devido a formação de um gel muito forte que pode ter dificultado a incorporação da emulsão de OE na matriz polimérica dos filmes. Os resultados de permeabilidade ao vapor de água mostraram que a adição de CaCl2 à formulação dos filmes diminuiu a permeabilidade enquanto a adição de OE cravo foi responsável pelo aumento dessa propriedade. Com relação às propriedades mecânicas, tanto a adição de CaCl2 como a de OE cravo à formulação dos filmes aumentou a resistência máxima à tração. Porém, com relação ao alongamento máximo na ruptura, valores menores foram obtidos com a adição de CaCl2, enquanto maiores valores foram encontrados com a adição de OE cravo à formulação dos filmes. A avaliação da atividade antimicrobiana dos filmes em carne de frango foi realizada somente com a formulação que apresentou os maiores valores de zona de inibição in vitro (CaCl2=0,0316% e OE cravo=0,884%). Após 5 dias de armazenagem a 7º C, observou-se que a utilização do filme adicionado de OE de cravo como embalagem primária em amostras de carne de peito de frango promoveu o controle da multiplicação de L. monocytogenes o mesmo não ocorrendo para as populações de Salmonella spp. e Pseudomonas spp. A análise sensorial relacionada ao aroma da carne de peito de frango mostrou que o uso do filme à base de alginato incorporado de OE cravo é viável. Porém, este filme poderá sofrer interferência da matriz alimentar caso esta matriz apresente exsudação. / The use of biodegradable packaging such as edible films and coatings are an alternative to the use of non-recyclable packaging. The incorporation of antimicrobial substances in packaging aims at reducing food microbial contamination among which, essential oils (EO) have received special attention being natural and attending consumer demand. However, the use of EO as a natural antimicrobial agent is limited by organoleptic criteria making it necessary to determine the minimum concentration to inhibit the multiplication of microorganisms without affecting the sensory characteristics of the food. Therefore, the aims of this research were: to develop an alginate based edible film with natural antimicrobial agents, evaluating the addition of different concentrations of calcium chloride as a crosslinking agent in the formulation of the film and in the complementary stage; to characterize the mechanical properties and barrier properties; to determine the minimum inhibitory concentration (MIC) of EO for Pseudomonas spp, Salmonella spp and Listeria monocytogenes found in chicken meat and to verify consumer acceptance of the product through sensorial analysis (aroma). Among the studied EO, the concentration of 0.2% of clove oil was effective in inhibiting the microorganisms tested, this concentration being the minimum limit used in the experimental design for film development. The independent variables studied in this design were calcium chloride in the range of 0.02 to 0.01% and clove EO in the range of 0.2 to 1.0%. Concentrations of CaCl2 above 0.0316%, independent of the EO concentration, reduced the inhibition zone of microbial growth in in vitro tests, possibly due to the formation of a very strong gel which could have made the incorporation of the EO emulsion in the polymeric matrix of the film very difficult. The results of water vapor permeability tests showed that the addition of CaCl2 to the formulation of the films reduced the permeability while the addition of clove EO increased this property. Regarding to mechanical properties, the addition of CaCl2 as well as clove EO to the film formulation increased the values of tensile strength. On the other hand, relating to elongation at the break, smaller values were obtained with the addition of the salt while the addition of EO provided higher values. The evaluation of antimicrobial activity of the films in chicken meat was performed only with the formulation that showed the highest inhibition values presented in vitro (CaCl2=0.0316% and clove EO=0.0884%). After five days of storage at 7° C, it was observed that the use of the film added by clove EO as primary packaging provided the control of L. monocytogenes growth in samples of chicken meat but not of Salmonella spp and Pseudomonas spp. The sensorial analysis - aroma - showed that the use of alginate based film incorporated with clove EO is viable in food. However, when the food matrix presents exudation, it can interfere in this film.

Made available in DSpace on 2014-07-29T15:22:56Z (GMT). No. of bitstreams: 1 Flavia.pdf: 881795 bytes, checksum: 03dfcba09ee19ab44534dd6e3140e212 (MD5) Previous issue date: 2007-10-26 / The spoilage of semicooked and cooked cheeses and semihard and hard cheeses, known as late blowing, has been the focus of some studies. Some microorganisms already had been related with this spoilage including some species of Clostridium, as C. tyrobutiricum, C. butyricum, C. sporogenes and C. beijerinckii. A new species, C. estertheticum, is being incriminated in the spoilage of cooled meats packed the vacuum, which presents similar characteristics to the late blowing in cheeses, as gas production with blowing of the packing, fort flavor of rancid and presence of acid butyl. However, did not have a story on the occurrence of C. estertheticum in raw milk and cheeses. The present work evaluated 32 samples of raw milk proceeding from country properties of Goiás and 95 samples of cheeses commercialized parmesan and provolone in the retail market of Goiânia, produced in different States of Brazil. C. estertheticum was detected using of the Polimerase Chain Reaction with two pairs of primers, RF/RR and 16SEF/16SER. The effect of the not-selective enrichment of the samples in broth BHI was evaluated, in three incubation periods, five, ten and 30 days 10ºC in anaerobes. The genomics DNA was extracted following the methodology fenol:clorofórmio. The gotten results disclose to the occurrence of C. estertheticum in samples of raw milk (34,4%) and samples of cheeses parmesan and provolone (17,9%). The highest leves of C. estertheticum was gotten in the cheeses parmesan and provolone with signals of spoilage (50,0%) and normal (29,6%) and in provolone with spoilage signals (25,0%). C. estertheticum was detected with the two pairs of primers used in the amplification, being the totality of positives only gotten when it associated the two pairs. The daily pay-enrichment for extraction of the genomics DNA substantially influenced in the detention of the microorganism being the period of 10 days, what it provided better resulted for pair RF/RR. C. estertheticum was found in samples of cheeses proceeding from all the analyzed States, and in raw milk samples harvested in Goiás, what it indicates its dissemination in Brazil / A deterioração de queijos semicozidos e cozidos ou semiduros e duros, conhecida como tufamento tardio, tem sido o foco de vários estudos. Alguns microrganismos já foram relacionados com esta deterioração incluindo algumas espécies de Clostridium, como C. tyrobutiricum, C. butyricum, C. sporogenes e C. beijerinckii. Uma nova espécie, C. estertheticum, está sendo incriminada na deterioração de carnes refrigeradas embaladas a vácuo, que apresenta características semelhantes ao tufamento tardio em queijos, como produção de gás com distensão da embalagem, forte odor de ranço e presença de ácidos butíricos. No entanto, não havia nenhum relato sobre a ocorrência de C. estertheticum em leite cru e queijos. O presente trabalho avaliou 32 amostras de leite cru provenientes de propriedades rurais de Goiás e 95 de queijos parmesão e provolone comercializados no mercado varejista de Goiânia, produzidos em diferentes Estados do Brasil. C. estertheticum foi detectado por meio da Reação em Cadeia da Polimerase com dois pares de primers, RF/RR e 16SEF/16SER. O efeito do enriquecimento não-seletivo das amostras em caldo BHI foi avaliado em três períodos de incubação, cinco, dez e 30 dias, a 10ºC em anaerobiose. O DNA genômico foi extraído seguindo a metodologia do fenol:clorofórmio. Os resultados obtidos revelam a ocorrência de C. estertheticum em amostras de leite cru (34,4%) e de queijos parmesão e provolone (17,9%). A maior positividade foi obtida nos queijos parmesão e provolone com sinais de deterioração (50,0%) e normais (29,6%) e no provolone com sinais de deterioração (25,0%). C. estertheticum foi detectado com os dois pares de primers utilizados na amplificação, sendo a totalidade de positivos obtida somente quando se associou os dois pares. O pré-enriquecimento para extração do DNA genômico influenciou substancialmente na detecção do microrganismo sendo o período de 10 dias, o que proporcionou melhores resultados para o par RF/RR. C. estertheticum foi encontrado em amostras de queijos provenientes de todos os Estados analisados, e em amostras de leite cru colhidos em Goiás, o que indica sua disseminação no Brasil

This diploma thesis is focused on the problematic of the smart packaging and deals with the preparation of disposable ammonia sensors/indicators and the subsequent color measurement of prepared sensors/indicators using the CIE L* a* b* color space. The theoretical part of the diploma thesis focuses on active and intelligent packaging, using ammonia sensors/indicators. The emphasis is placed on the main components of the sensor/indicator, i.e., chitosan as a polymer and curcumin as a dye. The theoretical part also includes the problematic of meat degradation, which plays a very important role in this thesis. The experimental part was divided into two parts. The first part was to prepare layers that will respond in different colors based on the concentrations of ammonia. Prepared layers were sensitive to ammonia across all concentrations, and based on this result, ascorbic acid was applied to compositions to achieve a calibration retention of the selected amount of ammonia. The second minor part of the experiment was the application of selected layers to packages with real meat.

The main objective of this study was the characterization of surface associated microbial communities in breweries. In addition, the beer-spoiling potential of isolated strains and biofilm samples was investigated. Some studies reported the identity of cultivatable organisms from industrial plants. However, there were no data available about the composition of biofilm communities from these habitats for cultivation-independent techniques. Consequently, the fatty acid methyl esters (FAMEs) analysis, the fluorescence in situ hybridization (FISH) and the construction and investigation of 16S rRNA gene clone libraries were applied to reveal the structure of these communities. All of these methods have different advantages and therefore, they complement each other to get a more reliable picture of the biofilm communities. The cultivation method was included in this study because it enables a verification of results from other studies. Furthermore, the obtained strains are genuine brewery isolates and can be used for physiological tests. Isolates were obtained from seven different sample sites (Chapter 1 and 5). They were identified and affiliated to 25 different genera. Some of these strains were inoculated in beer but none of them was able to grow in it (Chapter 1 and 5). However, these strains can still be harmful for the industry, e.g. if they are able to form biofilms. This aspect was investigated by analyzing the potential of the isolates to produce acyl-homoserine lactones (AHLs) (Chapter 6). These quorum sensing mediating molecules are involved in the maturation process of biofilms. Indeed, some strains were found to secrete these autoinducer molecules, they mainly belonged to the genus Pseudomonas. An abundant proportion among the isolates was constituted by members of the Enterobacteriaceae (Chapter 7). In the beginning of this study, there was a minor suspicion concerning their beer-spoiling potential. Indeed, all isolated Enterobacteriaceae were found to be able to multiply in non-alcoholic beer under access of oxygen but they represented no risk for filled beer. The beer-spoiling potential of biofilm communities was investigated by inoculating them in beer (Chapter 3). These enrichments allowed the detection of minor proportions of beer-spoiling organisms. About 25% of the biofilms contained microorganisms which were able to multiply in beer with 4.8% of ethanol (v/v). The absence of anaerobic beer-spoiling bacteria in most of the biofilms was confirmed by using specific FISH probes for Pectinatus and Megasphaera cells (Chapter 9). However, Pectinatus cells constituted one of the most abundant groups in two biofilm communities. These samples clearly demonstrated that brewery biofilms can become hazardous for the quality of the product. The acetic acid bacteria were supposed to be abundant brewery biofilm organisms. This was not confirmed by any method used (Chapter 8). Instead, FISH signals were found for many other taxa in considerable proportions, e.g. communities from the conveyors consisted of members of the Eukarya, Archaea, Alpha-, Beta-, Gammaproteobacteria, Cytophaga-Flavobacteria, Planctomycetales, Actinobacteria and Firmicutes (Chapter 1). Such diverse communities were also evidenced for three other biofilms analyzed by FISH (Chapter 2 and 9). Whereas the FISH technique allows the specific detection of single cells, the FAME analysis targets all organisms present, except the Archaea. The fatty acid profiles of 78 biofilms indicated significant differences between the communities, even between those which were exposed to similar conditions. In addition, repeated sampling of identical sites revealed a temporal variability of the microbial communities (Chapter 3). Characteristical fatty acids of beer-spoiling bacteria were almost absent. Typical fatty acids of Eukarya dominated nearly half of all biofilms. The high proportions of Eukarya in some biofilms was not confirmed, as these samples were also investigated by FISH. This divergence was found to be due to the higher biomass of eukaryotic cells compared to bacterial cells (Chapter 3). As some wild yeast strains were isolated and characterized, they are a potential source of these fatty acids. In contrast to the revealed bacterial diversity, most of the isolated yeasts were assigned to Saccharomyces or Candida spp. (Chapter 4). The Saccharomyces spp. showed a high beer-spoiling potential and many Candida species were able to form biofilms. The construction of 16S rRNA gene clone libraries and the analysis of the clones with amplified ribosomal DNA restriction analysis (ARDRA) was performed with two biofilm communities (Chapter 2). Clones with identical ARDRA patterns were grouped and some representatives were identified by sequencing. These clone sequences were affiliated to 30 different genera, most of which were members of the Alpha- and Gammaproteobacteria and the Bacteroidetes. In addition, some clone sequences were assigned to uncultured organisms. Despite of the presence of 53 and 59 different ARDRA patterns in the two clone libraries, respectively, they had only four patterns in common. This result underlined the differences in the microbial composition of these communities. In conclusion, breweries represent a habitat with high cleaning and disinfecting pressure, which might have selected for a limited number of more resistant or adopted species. Instead, the community structures of biofilms in industrial environments were found to be diverse and variable in their compositions.

Thesis (D. Tech. Environmental health) -- Central University of technology, Free State, 2011 / Apart from being the primary food source of many cultures around the world, fish contains notable amounts of essential fatty acids that are required by the human body, thus making fish a vital part of the human diet. In South Africa Cape hake is a well-known and highly consumed local fish species, which is transported from coastal areas countrywide where the fresh fish are displayed on ice in various retail stores. Fish is known to be highly susceptible to spoilage and, as a result, the maintenance of the cold-chain in related products is of particular importance. Additionally, recent trends showing a decline in natural fish resources have instigated growing concerns about the sustainability and optimal utilisation of fish as a food source. Against this backdrop, this study aimed at determining the influence of storage parameters on selected triglycerides and their possible metabolic pathways. Also applying prediction modelling of fatty acids and volatiles as instruments to assess exposure of Cape hake fillets to excessive microbial contamination and, in effect, be indicative of the environmental parameters (for example temperature) that may influence such contamination. Randomly selected juvenile hakes were filleted and stored under various simulated retail storage conditions, under either controlled or uncontrolled environmental conditions. For each hake filleted, one fillet was inoculated with an increased load of autochthonous microbiota, and the corresponding fillet was kept at similar temperature conditions. All fillets were monitored over a ten day period, during which fatty acid and volatile samples were collected and analysed. From the resulting triglycerides a selection of fatty acids were profiled and their possible metabolic pathways investigated. Fish maturity, the distribution of the fatty acids and the implication thereof in the nutritional value were also assessed. Conventional chemometric methods utilising mathematical expressions were subsequently utilised in order to predict contamination and whether the cold chain was sustained, while an artificial neural network (ANNs) were designed to predict excessive microbial contamination in the fillets. The results showed that the nutritional value of fish differs notably with its maturity and size. Mathematical equations were furthermore found to be effective assessment instruments to indicate the percentage differences in storage temperature, as well as consequent microbial influences. Thus, this approach may introduce mathematical prediction modelling as a promising mechanism to assess Cape hake spoilage. An artificial neural network (ANN) was successfully designed, that succeeded in distinguishing between Cape hake fillets displayed and stored on ice that have been exposed to excessive contamination and those that have not been exposed. In the latter case, the selected variable was a fatty acid, hexadecanoic acid, used as biochemical indicator. This modulating approach may provide a platform for future shelf-life studies on related muscle tissue. Ultimately, the study endeavoured to add to the body of knowledge regarding the biochemical and microbiological changes related to Cape hake storage, the prediction thereof via contemporary methods and contributing to the safety and effective utilization of this unique and declining South African nutritional resource.

Thesis (PhD (Food Science))--University of Stellenbosch, 2009. / ENGLISH ABSTRACT: Species of Alicyclobacillus are acid-tolerant and heat-resistant bacteria that cause spoilage of heat-treated fruit juices stored at room temperature. During the past decade, Alicyclobacillus spp. have become a major cause of spoilage in pasteurised fruit juices leading to significant economic losses world-wide. Spoilage has been reported in apple, pear, orange, peach, mango and white grape juice, as well as in fruit juice blends, fruit juice containing drinks and tomato products, such as tomato juice and canned tomatoes. Spoilage is characterised by a medicinal smell and guaiacol production. These endospore-formers have been shown to survive pasteurisation conditions of 95 °C for 2 min, grow at temperatures between 25° and 60 °C and a pH range of 2.5 to 6.0. Knowledge of this organism is limited, both locally and internationally and the route of contamination to the final product is not well established. In this study the fruit concentrate processing environment was investigated as a potential source and route of contamination for the final product. Species of Alicyclobacillus were isolated from orchard soil, various stages during processing and from fruit juice and concentrates. The isolates were identified based on morpholological, biochemical and physiological properties. Identification to species level was done by 16S ribosomal RNA gene sequencing and strain differentiation by RAPD-PCR. Results indicate that species of A. acidoterrestris and Alicyclobacillus acidocaldarius were found in orchard soil and throughout the processing environment. This is the first report on the isolation of these species from orchard soil, vinegar flies and the fruit processing environment. The 16 isolates identified as A. acidoterrestris grouped into four clusters based on RAPD-PCR banding patterns, suggesting that they belong to at least four genotypic groups. Isolates from the fruit concentrate, wash water and soil located outside of the fruit processing plant grouped into one cluster. Concluded from these results, A. acidoterrestris found in the wash water and soil outside of the factory could act as a potential reservoir of organisms for the contamination of the final fruit concentrate. Thus good manufacturing practices play an essential role in controlling incidence of spoilage caused by these bacteria. Fruit juices can be treated using ultraviolet (UV-C) light with a wavelength of 254 nm, which has a germicidal effect against micro-organisms. Alicyclobacillus acidoterrestris spores were inoculated into tap water, used wash water from a fruit processing plant and grape juice concentrate. Ultraviolet dosage levels (J L−1) of 0, 61, 122, 183, 244, 305 and 367 were applied using a novel UV-C turbulent flow system. The UV treatment method was shown to reliably achieve in excess of a 4 log10 reduction (99.99%) per 0.5 kJ L-1 of UV-C dosage in all the liquids inoculated with A. acidoterrestris. The applied novel UV technology could serve as an alternative to thermal treatments of fruit juices for the inactivation of Alicyclobacillus spores or in the treatment of contaminated processing wash water. Finally, the thermal inactivation at 95 °C for two strains of A. acidoterrestris isolated from contaminated fruit juice concentrates were investigated in a 0.1% (m/v) peptone buffer solution (pH 7.04) and grape juice (pH 4.02, 15.5 °Brix). The thermal inactivation of A. acidoterrestris spores followed first-order kinetics, suggesting that as the microbial population is exposed to a specific high temperature, the spores inactivated at a constant rate. D-values determined in the buffer solution were calculated to be 1.92 min and 2.29 min, while in grape juice D-values were found to be 2.25 min and 2.58 min for the two strains tested. From this study it is clear that the D-value is dependant on the strain tested, but also on the soluble solids of the solution the cells are suspended in. The results indicated that the spores of A. acidoterrestris isolated from South African fruit juice concentrate may survive after the pasteurisation treatment commonly applied during manufacturing. / AFRIKAANSE OPSOMMING: Spesies van Alicyclobacillus is suur-tolerante en hittebestande bakterieë wat bederf veroorsaak in hitte-behandelde vrugtesappe wat teen kamertemperatuur gestoor word. Gedurende die afgelope dekade het Alicyclobacillus spp. ‘n belangrike oorsaak van bederf in gepasteuriseerde vrugtesappe geword en beduidende ekonomiese verliese wêreldwyd veroorsaak. Bederf is aangeteken in appel-, peer-, lemoen-, perske-, mango- en witdruiwesap, sowel as in vrugtesapversnitte, vrugtesapbevattende drankies en in tamatieprodukte soos tamatiesap en ingemaakte tamaties. Bederf word gekenmerk deur ’n medisinale reuk en guaiacol produksie. Daar is gevind dat hierdie endospoorvormers pasteurisasie teen 95 °C vir 2 min kan oorleef en kan groei by temperature tussen 25° en 60 °C en ‘n pH van 2.5 to 6.0. Plaaslik sowel as internasionaal is kennis van hierdie organisme beperk en die roete van kontaminasie van produkte is nog nie goed vasgestel nie. In hierdie studie is die vrugtekonsentraat-verwerkingsmilieu ondersoek as ‘n moontlike bron en roete van kontaminasie van die finale produk. Spesies van Alicyclobacillus is vanuit vrugteboordgrond, verskeie verwerkingstadia en van vrugtesap en vrugtesapkonsentraat geïsoleer. Die isolate is op grond van morfologiese, biochemiese en fisiologiese eienskappe geïdentifiseer. Identifikasie tot spesiesvlak is deur 16S rDNS sekwensering gedoen en stam differensiasie deur RAPD-PKR. Resultate het aangetoon dat A. acidoterrestris en A. acidocaldarius in vrugteboordgrond sowel as in alle stadia van die verwerkingsmilieu voorkom. Dit is die eerste verslag van die isolering van hierdie spesies uit die Suid-Afrikaanse vrugteverwerkingsmilieu, vrugteboordgrond en asynvlieë. Die 16 isolate, geïdentifiseer as A. acidoterrestris en in vier groepe geplaas op grond van hul RAPD-PKR bandpatrone, dui aan dat hulle aan minstens vier genotipiese groepe behoort. Isolate afkomstig van die vrugtekonsentraat, waswater en die grond buitekant die vrugteverwerkingsaanleg het een groep gevorm. Uit hierdie resultate kan afgelei word dat A. acidoterrestris, wat in die waswater en grond buite die aanleg voorkom, as ‘n moontlike bron van organismes vir die kontaminering van die finale vrugtekonsentraat kan dien. Goeie vervaardigingspraktyke speel dus ‘n noodsaaklike rol in die beheer van bederf veroorsaak deur hierdie bakterieë. Vrugtesappe kan behandel word met ultravioletlig (UV-C) met ‘n golflengte van 254 nm wat ‘n dodende effek op mikro-organismes het. Kraanwater, gebruikte waswater van ‘n vrugtesapvervaardigingsaanleg en druiwesapkonsentraat is met A. acidoterrestris spore geïnokuleer. Ultraviolet toedieningsvlakke (J L−1) van 0, 61, 122, 183, 244, 305 en 367 is aangewend met behulp van ‘n nuwe UV-C drukvloei stelsel. Daar is aangetoon dat die UV-behandelingsmetode ‘n betroubare vermindering (99.99%) van meer as 4 log10 per 0.5 kJ L-1 van ‘n UV-C dosis gee in al die vloeistowwe wat geïnokuleer is met A. acidoterrestris. Die toegepaste nuwe UV-tegnologie kan gebruik word as ‘n alternatief tot die hittebehandeling van vrugtesap vir die deaktivering van Alicyclobacillus spore of in die behandeling van gekontamineerde waswater. Ten slotte is hitte-deaktivering teen 95 °C van twee stamme van A. acidoterrestris, geïsoleer uit gekontamineerde vrugtesapkonsentraat, in ‘n 0.1% (m/v) peptoonbufferoplossing (pH 7.04) en druiwesap (pH 4.02, 15.5 °Brix), ondersoek. Die hitte-deaktivering van A. acidoterrestris spore het eerste-orde kinetika gevolg, wat aandui dat die mikrobe-populasie teen ‘n konstante tempo afsterf, wanneer blootgestel aan ‘n spesifieke hoë temperatuur. Die D-waardes in die bufferoplossing is bereken as 1.92 min en 2.29 min, terwyl daar gevind is dat die D-waardes in druiwesap 2.25 min en 2.58 min is vir die twee betrokke stamme. Vanuit hierdie studie is dit duidelik dat die D-waardes afhang van die betrokke stam, maar ook van die oplosbare vaste stowwe van die oplossing waarin die selle opgelos is. Die resultate dui daarop dat die spore van A. acidoterrestris, wat geïsoleer is uit Suid-Afrikaanse vrugtesapkonsentraat, die pasteurisasiebehandeling wat algemeen tydens vervaardiging toegepas word, kan oorleef. Aangesien die toepassing van strenger hittebehandeling om spore van A. acidoterrestris te deaktiveer onaanvaarbare organoleptiese veranderinge in die produk tot gevolg het, word dit aanbeveel dat die risiko van bederf verminder behoort te word deur die gebruik van goeie vervaardigingspraktyke gedurende vrugteverwerking.

Les moisissures d’altération sont à l’origine de pertes alimentaires et économiques importantes et certaines espèces peuvent présenter un danger pour la santé humaine et animale avec la production de mycotoxines. Dans ce contexte, la maîtrise de la qualité et de la sécurité des aliments passe par une bonne connaissance des espèces impliquées. Cette connaissance repose sur une identification fiable et rapide et l’obtention d’informations sur les facteurs abiotiques impactant leur développement, tels que les conservateurs, largement utilisés dans l’industrie. Dans ce cadre, les objectifs de thèse étaient de développer l’utilisation de la spectrométrie de masse MALDI-TOF pour l’identification des moisissures et d’évaluer son application à la résolution de complexe d’espèces et au typage, et enfin d’évaluer la néphélométrie laser pour mesurer en haut-débit leur croissance en présence de conservateurs. Dans un premier temps, une base de données robuste a été construite avec près de 6500 spectres correspondant à 136 espèces fongiques. Dans un deuxième temps, la technique MALDI-TOF a été appliquée avec succès à la différenciation de 23 espèces du complexe Aspergillus section Flavi et a permis de différencier des isolats de Penicillium roqueforti appartenant à 3 populations génétiquement différenciées. Enfin, la néphélométrie laser a permis un suivi haut-débit de la croissance de 14 espèces fongiques d’altération en présence de 3 conservateurs et ainsi d’obtenir des informations sur les concentrations minimales inhibitrices de ces derniers. Ces travaux ont démontré l’applicabilité de techniques alternatives permettant d’identifier et de caractériser les moisissures d’altération. / Spoilage fungi represent a major cause of food and economic losses and certain species, which may produce mycotoxins, may also pose a threat to human and animal health. Thus, food safety and quality management relies notably on a good knowledge of the involved species. This knowledge is notably based on their fast and reliable identification and on the study of abiotic factors affecting their growth such as food preservatives, which are commonly used in the food industry. In this context, the objectives of this PhD. thesis were to develop MALDI-TOF mass spectrometry for mold identification and to evaluate its potential for species complex differentiation and strain typing, and finally, to evaluate the use of laser nephelometry to monitor fungal growth in the presence of food preservatives.First, a robust database was developed with 6500 spectra corresponding to 136 spoilage fungi. Then, MALDI-TOF MS was successfully applied to differentiate 23 species of Aspergillus section Flavi and Penicillium roqueforti isolates belonging to 3 genetically distinct populations.Finally, in 14 fungal species, laser nephelometry allowed a high-throughput monitoring of their growth after exposition to 3 different food preservatives and the determination of their associated minimal inhibitory concentrations.Overall, the obtained results demonstrate the usefulness of alternative techniques for identification and characterization of food spoilage fungi.